file:///C|/Documents%20and%20Settings/bob/My%20Documents/manualdirectory.htm
This file was downloaded and provided FREE OF CHARGE
from the ManualDirectory community.
You can find many free to download Service Manuals & Schematics at
http://www.manualdirectory.co.uk
file:///C|/Documents%20and%20Settings/bob/My%20Documents/manualdirectory.htm01/04/2007 01:34:00
ORDER NO.
PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan
PIONEER ELECTRONICS SERVICE, INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE N.V. Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2000
SH-D505
DIGITAL TUNER
ARP3054
TZZV FEB. 2000 Printed in Japan
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
Type
Model
SH-D505
Power Requirement
Remarks
KU
AC120V
1. SAFETY INFORMATION .................................... 2
2. EXPLODED VIEWS AND PARTS LIST ............. 3
3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM
......................................................... 6
4. PCB CONNECTION DIAGRAM ....................... 40
5. PCB PARTS LIST ............................................. 46
6. ADJUSTMENT .................................................. 61
CONTENTS
7. GENERAL INFORMATION .............................. 67
7.1 TROUBLE SHOOTING TABLE .................. 67
7.2 CHASSIS LAYOUT ..................................... 71
8. PANEL FACILITIES AND SPECIFICATIONS
....................................................... 73
· The supplied service parts are only listed at page 3 and 5.
· The parts listed at page 47 to page 60 are not supplied as
service parts.
2
SH-D505
1. SAFETY INFORMATION
This service manual is intended for qualified service technicians ; it is not meant for the casual do-it-
yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained
to properly and safely repair complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may
void the warranty. If you are not qualified to perform the repair of this product properly and safely, you
should not risk trying to do so and refer the repair to a qualified service technician.
WARNING
This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to cause
cancer, birth defects or other reproductive harm.
Health & Safety Code Section 25249.6 Proposition 65
NOTICE
(FOR CANADIAN MODEL ONLY)
Fuse symbols
(fast operating fuse) and/or
(slow operating fuse) on PCB indicate that replacement parts must
be of identical designation.
REMARQUE
(POUR MODÈLE CANADIEN SEULEMENT)
Les symboles de fusible
(fusible de type rapide) et/ou
(fusible de type lent) sur CCI indiquent que les pièces
de remplacement doivent avoir la même désignation.
ANY MEASUREMENTS NOT WITHIN THE LIMITS
OUTLINED ABOVE ARE INDICATIVE OF A POTENTIAL
SHOCK HAZARD AND MUST BE CORRECTED BEFORE
RETURNING THE APPLIANCE TO THE CUSTOMER.
2. PRODUCT SAFETY NOTICE
Many electrical and mechanical parts in the appliance
have special safety related characteristics. These are
often not evident from visual inspection nor the protection
afforded by them necessarily can be obtained by using
replacement components rated for voltage, wattage, etc.
Replacement parts which have these special safety
characteristics are identified in this Service Manual.
Electrical components having such features are identified
by marking with a
on the schematics and on the parts list
in this Service Manual.
The use of a substitute replacement component which does
not have the same safety characteristics as the PIONEER
recommended replacement one, shown in the parts list in
this Service Manual, may create shock, fire, or other hazards.
Product Safety is continuously under review and new
instructions are issued from time to time. For the latest
information, always consult the current PIONEER Service
Manual. A subscription to, or additional copies of, PIONEER
Service Manual may be obtained at a nominal charge from
PIONEER.
1. SAFETY PRECAUTIONS
The following check should be performed for the
continued protection of the customer and service
technician.
LEAKAGE CURRENT CHECK
Measure leakage current to a known earth ground (water
pipe, conduit, etc.) by connecting a leakage current tester
such as Simpson Model 229-2 or equivalent between the
earth ground and all exposed metal parts of the appliance
(input/output terminals, screwheads, metal overlays, control
shaft, etc.). Plug the AC line cord of the appliance directly
into a 120V AC 60Hz outlet and turn the AC power switch
on. Any current measured must not exceed 0.5mA.
(FOR USA MODEL ONLY)
Leakage
current
tester
Reading should
not be above
0.5mA
Device
under
test
Test all
exposed metal
surfaces
Also test with
plug reversed
(Using AC adapter
plug as required)
Earth
ground
AC Leakage Test
SH-D505
3
2. EXPLODED VIEWS AND PARTS LIST
NOTES :
Parts marked by " NSP " are generally unavailable because they are not in our Master Spare Parts List.
The
mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Remote Control
Polystyrene Cover
Cushion L,R
Using the Operation Manual bag tape,
seal the bag too.
Accessories
Instruction Manual
RCA Pin Cable Set
Warranty Card
Battery
Wrap the AC power cord with the top
mirror foil. Apply the tape onto the
bottom mirror foil, the AC power cord
mirror foil and the Operation Manual
bag. (Do not apply the tape direct on
the AC power cord).
The packing case
top is tape sealed.
Packing Case
Bar Code Serial
No. Label
Front
2.1 PACKING
ACCESSORIES
RRMCG1528CESA
Remote Control
TiNS-6851MEZZ
Instruction Manual (English)
ADF1011
RCA Pin Cable Set
NSP
UBATU0001AJZZ
Battery
NSP
ARY7023
Warranty Card
ACCESSORIES
(NOT REPLACEMENT ITEM)
PACKING PARTS
SPAKC0650MEZZ
Packing Case
SPAKP0041MEZZ
Polystyrene Cover
SPAKX0183MEZZ
Cushion L,R
SSAKA0005MEZZ
Polyethylene Bag
SUPPLIED ACCESSORIES
Ref. No.
Part No.
Description
SH-D505
4
2.2 EXTERIOR SECTION
A
B
B
C
C
J
H
I
E
D
D
E
A
F
G
F
G
J
H
I
1
7
1-1
42
2
2-3
2-2
2-5
2-4
20
24
26
44
7
2-1
1-3
1-4
26
39
21
18
10
15
13
41
8
19
43
11
9
35
11
37
26
22
12
26
20
16
47
24
23
23
6
36
42
23
23
23
1-5
1-5
38
38
14
20
1-6
1-7
1-2
34
23
23
4
4
5
23
29
28
31
33
32
27
45
46
17
5
3
5
25