ORDER NO.
PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan
PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2002
RRV2666
T ZZM SEPT. 2002 Printed in Japan
S-DV620
S-DV620
XTW/UC
SPEAKER SYSTEM
FOR PRECAUTION OF
REASSEMBLY AND DISASSEMBLY
65S
This service manual is intended for qualified service technicians; it is not meant
for the casual do-it-yourselfer. Qualified technicians have the necessary test
equipment and tools, and have been trained to properly and safely repair complex
products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability
of the product and may void the warranty. If you are not qualified to perform the
repair of this product properly and safely, you should not risk trying to do so and
refer the repair to a qualified service technician.
WARNING
This product contains lead in solder and certain electrical parts contain chemicals
which are known to the state of California to cause cancer, birth defects or other
reproductive harm.
Health & Safety Code Section 25249.6 Proposition 65
Subwoofer
Center
Front / Surround
CS Assy ( Subwoofer )
The grille Assy is attached to the cabinet by press-fitting with
adhesive. To detach it, pry it open by inserting a flat blade
screwdriver into backside of it. To attach it, clean the press-
fitting part and apply a bit of adhesive . Then press it to the
bafle.
The subwoofer is attached to the baffle by 4 external screws.
To detach it, unfasten those screws.
When attaching it, face its terminal upward.
CS Assy ( Front / Surround Speaker )
The grille Assy is attached to the cabinet by 4 screws. To detach
it, unfasten those screws.
The speaker unit is attached to the cabinet by 4 external screws
together with the grille Assy. To detach it, first unfasten those
screws. Next remove the cabinet. Then remove the speaker
wire. When attaching it, face its terminal toward the input ter-
minal.
CS Assy ( Center Speaker )
The grille Assy is attached to the cabinet by 4 screws. To detach
it, unfasten those screws.
The speaker unit is attached to the grille Assy by 4 internal
screws.
To detach it, first unfasten those screws. Next remove the cabi-
net. Then remove the speaker wire. When attaching it, face its
terminal toward the input terminal.
2
1
23
4
12
3
4
C
D
F
A
B
E
S-DV620
Mark No.
Description
Part No.
CS ASSY (FS)
Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List.
The
mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
NOTES:
PARTS LIST
Mark No.
Description
Part No.
NSP
CS ASSY(SW)
SMW1737
NSP
CS ASSY(FS)
SMW1738
NSP
CS ASSY(C)
SMW1739
For Packing
NSP
Accessary Set
SEA1593
Speaker Wire (White)
SDS1108
Speaker Wire (Red)
SDS1109
Speaker Wire (Blue)
SDS1110
Speaker Wire (Gray)
SDS1111
Speaker Wire (Green)
SDS1112
Speaker Wire (Purple)
SDS1113
Non Skid Pads (for FS, C)
SEP1240
Non Skid Pad (FOR SW)
SEP6001
NSP
Polyethylene Bag
SHL1251
Top Protector
SHA2350
Middle Protector
SHA2351
Bottom Protector
SHA2352
Protection Sheet
SHC1787
Packing Case
SHG2440
Polyethylene Bag
SHL1252
NSP
Cabinet
SMM1975
NSP
Label Back
SAN3144
Cable
SDD1313
Packing
SEC1627
NSP
Damper
SER1324
Input Terminal
SKX1060
Grille
SMG1768
NSP
Grille Cloth
SAS1533
NSP
Grille Frame
SMH1055
NSP
Cosmetic Duct
SMR1355
NSP
Paper Tube 50
SMR1359
NSP
Acoustic Absorbent (for Side)
SMV2123
NSP
Acoustic Absorbent (for Bottom)
SMV2138
NSP
Port Tube Ring 50
SNK2572
NSP
Cosmetic Baffle
SNK2602
NSP
Cosmetic Plate
SNK2603
Speaker
P14LR83-51D
Screw (for Cosmetic Duct)
BPZ40P100FMC
Screw (for Speaker)
BYC40P200FZB
NSP
Staple 80/6 BEA
ZMA-8006B
Mark No.
Description
Part No.
CS ASSY (SW)
Grille
SMG1769
NSP
Badge 23
SAM1490
NSP
Grille Cloth
SAS1534
NSP
Baffle
SNK2549
NSP
Cabinet
SNK2548
NSP
Model Label (FL)
SAN3148
NSP
Model Label (FR)
SAN3152
NSP
Model Label (SL)
SAN3156
NSP
Model Label (SR)
SAN3160
Fung Nut M5
SBN1044
Speaker Wire
SDD1275
Packing
SEC1479
In-Put Terminal
SKX1062
NSP
Acoustic Absorbent
SMV2124
NSP
Caution Label
SRW1075
Speaker
D87DU61-52D
Screw
BPZ40P100FZB
Grille
SMG1770
NSP
Badge 23
SAM1490
NSP
Grille Cloth
SAS1535
NSP
Baffle
SNK2552
NSP
Cabinet
SNK2551
NSP
Model Label (C)
SAN3164
Speaker Wire
SDD1275
Packing
SEC1479
In-Put Terminal
SKX1062
NSP
Acoustic Absorbent
SMV2124
Speaker
D87DU61-52D
Screw (for Speaker)
BPZ40P060FZB
Screw (for Grille)
BPZ40P100FZB
CS ASSY (C)
Mark No.
Description
Part No.
3
1
23
4
1
2
3
4
C
D
F
A
B
E
S-DV620
SCHEMATIC DIAGRAM
Woofer
INPUT
Red
Black
Cable (SDD1313)
Woofer
INPUT
Red
White
Speaker Wire (SDD1275)