ORDER NO.
PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan
PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2007
PDP-S59
RRV3571
SPEAKER SYSTEM
PDP-S59
XTW/E5
* Be careful in handling this product, because scratches on cabinet coating are easily
noticeable. When working on this unit, be sure to place the cabinet on a piece of
soft cloth for protection.
SERVICE PRECAUTIONS
T-ZZR APR. 2007 Printed in Japan
PDP-S59
2
12
3
4
12
3
4
C
D
F
A
B
E
1. REASSEMBLY AND DISASSEMBLY PRECAUTIONS
1.1 GRILLE ASSY
The Grill Assy is secured to the baffle plate with two-sided tape and
bosses. When removing the Grill Assy, if is necessary to wear cot-
ton gloves.
Disassembly
1. Insert the tip of your gloved finger into the gap between the
Grill Assy in front and the corner of the baffle plate so that the
Grill Assy is slightly lifted.
2. Insert the gloved finger to the extent of the second joint into the
gap between the cabinet and the Grill Assy.
3. Alternately and gradually lift the left and right sides of the Grill
Assy by about 5 cm, sliding gloved fingers along the cabinet. When
lifting the Grill Assy, be sure to lift the left and right sides alternate-
ly, but not both sides simultaneously.
Note: Be careful not to bend the Grill Assy too far. Otherwise, it
may be damaged.
O : Good example X : Bad example
Reasassembly
When reassembling the Grill Assy
Remove the old two-sided tape attached to the rear panel of the
Grill Assy and adhere new two-sided tape. Press the bosses into the
baffle plate and press the entire grill into position.
1.2 WOOFER (Disassembly)
The woofer is secured to the baffle plate with four screws from the
outside. To remove the woofer, first remove the baffle plate. (Re-
move the baffle plate first, because the cables from the Network
Assy are short.)
Reasassembly
When reassembling the woofer, place it so that its connector plate
is facing downward.
1.3 TWEETER (Disassembly)
The tweeter is secured to the baffle plate with three screws from
the outside. To remove the tweeter, first remove the baffle plate.
(Remove the baffle plate first, because the cables from the Net-
work Assy are short.)
Reasassembly
When reassembling the tweeter, place it so that its connector and
screw -hole positions aliga with those on the baffle plate.
Network Assy (Caution)
· When removing the Network Assy, pull it out a little at a time
from alternate sides, because it is seated tightly.
Baffle Assy (Caution)
· When reassembling the cabinet and the baffle plate, secure the
screws in the order shown in the figure below:
Grille ASSY
Baffle
Grille ASSY
Baffle
Network ASSY
1
2
1
Input terminal
Baffle
5
4
3
2
1
PDP-S59
3
5
678
56
7
8
C
D
F
A
B
E
2. EXPLODED VIEWS AND PARTS LIST
2.1 PACKING
PACKING parts List
NOTES :
· Parts marked by " NSP " are generally unavailable because they are not in our Master Spare Parts List.
· The
> mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Up
Mark No.
Description
Part No.
NSP 1
1..Accessory Set
SME3775
2
2..Speaker Wire
SDS1202
3
2..Polyethylene Bag S1
SHL1439
NSP 4
2..Screws Set
SME3696
5
3..Screw
BMZ50P100FTB
6
3..Polyethylene Bag S0
SHL1438
7
1..Bracket Assy(S)
SXG1125
8
2..Gasket
SEC2040
9
2..Gasket
SED1136
10
. . . .
11
2..Gasket
SED1138
NSP 12
2..Bracket (S)
SNA1475
13
1..Bracket ASSY(S)
SXG1125
14
2..Gasket
SEC2040
15
2..Gasket
SED1136
16
. . . .
17
2..Gasket
SED1138
NSP 18
2..Bracket (S)
SNA1475
19
1..Bracket ASSY(C)
SXG1126
20
2..Gasket
SED1140
21
2..Gasket
SED1141
22
2..Gasket
SED1142
NSP 23
2..Bracket (C)
SNA1476
24
Form Pad(Side)
SHA2544
25
Form Pad(C-T)
SHA2545
26
Form Pad(C-M)
SHA2546
27
Form Pad(C-B)
SHA2547
28
Protection Sheet S3
SHC1846
29
Protection Sheet S1
SHC1847
30
Spacer
SHD1072
31
Packing Case
SHG2778
32
Packing Bag S2
SHL1450
33
Polyethylene Bag S0
SHL1451
NSP 34
CS ASSY
SMW1977
NSP 35
1..Inst. Manual Set
SME3779
36
2..Polyethylene bag s2
SHL1437
37
2..Operating Instructions
SRD1335
(English, French, German,
Italian, Dutch, Spanish, Chinese)
NSP 38
Label
SRW1112
Mark No.
Description
Part No.
PDP-S59
4
12
3
4
12
3
4
C
D
F
A
B
E
2.2 SPEAKER SYSTEM (CS ASSY)
12
13
10
16
Tweeter
16
2
26
Input Terminal
Baffle
(bac
k)
Cabinet
(inside)
PDP-S59
5
5
678
56
7
8
C
D
F
A
B
E
BAFFLE
CS ASSY parts List
22
Mark No.
Description
Part No.
NSP 1
Baffle
SNK2976
NSP 2
1..Cabinet ASSY L
SXG1123
NSP
2..Insert Nut M5
SBN1073
NSP
2..Cabinet L
SNK2968
NSP 3
1..Cabinet ASSY R
SXG1124
NSP
2..Insert Nut M5
SBN1073
NSP
2..Cabinet R
SNK2969
NSP 4
1..Cabinet ASSY C
SXG1122
NSP
2..Insert Nut M5
SBN1073
NSP
2..Cabinet C
SNK2970
5
1..Grille ASSY
SMG1885
NSP
2..Grille Cloth
SAS1623
NSP
2..Felt
SED1179
2..Tape
SEH1100
2..Tape
SEH1089
2..Tape
SEH1090
NSP
2..Grille Frame
SMH1121
NSP
2..Cosmetic Frame
SNK2971
6
. . . .
7
. . . .
8
Network ASSY
SWN1787
NSP 9
Model Label
SAN3953
NSP 10
Gasket
SEB1299
NSP 11
Gasket
SEB1300
12
Gasket (Baffle)
SEC2073
NSP 13
Gasket
SEC2074
14
Gasket (Baffle Cabi)
SEC2076
NSP 15
Gasket
SEC2078
16
Gasket (Tweeter)
SEC2083
NSP 17
Gasket
SEC2134
NSP 18
Gasket
SEC2113
NSP 19
Gasket
SEC2114
NSP 20
Gasket
SEC2092
NSP 21
Gasket
SEC2093
NSP 22
Gasket
SEC2094
NSP 23
Felt
SED1127
NSP 24
Felt
SED1130
25
Tape (Baffle)
SEH1113
26
1..Input Terminal
SKX1098
NSP
2..Spring
SBH1003
NSP
2..Terminal
SKF1064
NSP
2..Terminal
SKF1065
NSP
2..Case
SNK2909
NSP
2..Lever (Black)
SNK2910
NSP
2..Lever (Red)
SNK2911
27
. . . .
28
. . . .
29
. . . .
30
. . . .
31
. . . .
NSP 32
Acoustic Absorbent
SMT1358
NSP 33
MDF Bar
SLX1165
NSP 34
Paper Tube 26
SMR1403
NSP 35
Acoustic Absorbent
SMT1331
NSP 36
Acoustic Absorbent
SMT1333
NSP 37
Acoustic Absorbent
SMT1359
NSP 38
Acoustic Absorbent
SMT1335
NSP 39
Acoustic Absorbent
SMT1336
NSP 40
Acoustic Absorbent
SMT1357
NSP 41
Caution Label
SRR1024
NSP 42
Label Serial
SRW1111
43
Speaker
H132DC65-51D
44
Speaker
FK26AP32-55H
45
Screw
BPZ30P080FTC
46
Screw
BPZ35P080FTC
47
Screw
BPZ35P120FTB
48
Screw
BPZ35P120FTC
49
Screw
BPZ35P140FTC
50
Screw
BPZ40P350FTC
Mark No.
Description
Part No.