ORDER NO.
PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan
PIONEER ELECTRONICS SERVICE, INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Allexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2000
c
RRV2372
DVD-R7211
1. SAFETY INFORMATION ....................................... 2
2. EXPLODED VIEWS AND PARTS LIST ................. 4
3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM 12
4. PCB CONNECTION DIAGRAM ........................... 36
5. PCB PARTS LIST ................................................ 44
6. ADJUSTMENT ..................................................... 48
CONTENTS
7. GENERAL INFORMATION .................................. 69
7.1 DIAGNOSIS ................................................... 69
7.1.1 DISASSEMBLY ..................................... 69
7.1.2 ACQUIRING THE DRIVE STATUS ....... 73
7.1.3 LED LIGHTING SPECIFICATIONS ....... 73
7.1.4 SCSI ERROR CODE TABLE ................. 74
7.1.5 AGING MODE ....................................... 78
7.2 PARTS ........................................................... 80
7.2.1 IC .......................................................... 80
8. PANEL FACILITIES AND SPECIFICATIONS ..... 104
T ZZY SEPT. 2000 Printed in Japan
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
DVD-R DRIVE UNIT
Remarks
Type
Model
DVD-R7211
Power Requirement
ZUCYV/WL
O
DC Power supply from other system
NECESSARY INFORMATION FOR DHHS RULES
MARKED ON THE TOP COVER BELOW:
CAUTION LASER RADIATION WHEN OPEN.
DO NOT STARE INTO BEAM
DVD-R7211
2
1. SAFETY INFORMATION
This service manual is intended for qualified service technicians; it is not meant for the casual
do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been
trained to properly and safely repair complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may
void the warranty. If you are not qualified to perform the repair of this product properly and safely, you
should not risk trying to do so and refer the repair to a qualified service technician.
WARNING
This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to cause
cancer, birth defects or other reproductive harm.
Health & Safety Code Section 25249.6 Proposition 65
IMPORTANT
The pickup of this device conforms to Class 3A of the FDA Laser Restrictions
(CFR21 PART 1040), and the device, which conforms to Class A as a total
product, is not to be disassembled for repair in the U.S.A. or its territories.
In other districts, the device must be disassembled for repair only by a
specially instructed person with sufficient care against laser light.
VARO!
AVATTAESSA
JA
SUOJALUKITUS
OHITETTAESSA
OLET
ALTTIINA
NÄKYMÄTTÖMÄLLE
LASERSÄTEIYLLE.
ÄLÄ KATSO SÄTEESEEN.
ADVARSEL :
USYNLIG LASERSTRÅLING VED ÅBNING
NÅR SIKKERHED SAFBRYDERE ER UDE AF
FUNKTION.
UNDGÅ
UDSÆTTELSE
FOR
STRÅLING.
VARNING!
OSYNLIG LASERSTRÅLNING NÄR DENNA
DEL
ÄR
ÖPPNAD
OCH
SPÄRREN
ÄR URKOPPLAD. BETRAKTA EJ STRÅLEN.
WARNING!
DEVICE INCLUDES LASER DIODE WHICH
EMITS INVISIBLE INFRARED RADIATION
WHICH IS DANGEROUS TO EYES. THERE IS
A WARNING SIGN ACCORDING TO PICTURE
1 INSIDE THE DEVICE CLOSE TO THE LASER
DIODE.
IMPORTANT
THIS PIONNER APPARATUS CONTAINS
LASER OF CLASS 1.
SERVICING OPERATION OF THE APPARATUS
SHOULD BE DONE BY A SPECIALLY
INSTRUCTED PERSON.
LASER
kuva 1
Lasersateilyn
varoitusmerkki
LASER
Picture 1
Warning sign for
laser radiation
LASER DIODE CHARACTERISTICS
MAXIMUM OUTPUT POWER : 35 mw
WAVELENGTH : 658 nm
DVD-R7211
3
1. The ON/OFF(ON:low level,OFF:high level) status of the
CLAMP signals for detcting the loading state are detected
by the drive CPUs, and the design prevents laser diode
oscillation when the CLAMP signal turns OFF.
In normal operation, if no disc is clamped, the laser diode
oscillation is disabled.
However, the interlock does not always operate in the test
mode.
*
2. When the cover is opened, close viewing of the objective
lens with the naked eye will cause exposure to a Class 3A
laser beam.
Additional Laser Caution
* Refer to page 50.
DRW1946
DAL1139
7LABEL CHECK
DVD-R7211
4
2. EXPLODED VIEWS AND PARTS LIST
NOTES :
÷ Parts marked by " NSP " are generally unavailable because they are not in our Master Spare Parts List.
÷ The
mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
÷ Screw adjacent to
mark on the product are used for disassembly.
2.1 PACKING
4
2
1
3
9
7
8
6
5
DVD-R7211
5
NSP
1
Warranty Card
ARY1093
2
Operating Instructions
DRC1134
(English/ French/ German/ Japanese)
NSP
3
Polyethylene Bag
Z21-010
(100x 230x 0.018)
NSP
4
Polyethylene Bag
Z21-038
(230x 340x 0.03)
5
Pad
DHA1471
6
Pad
DHA1472
7
Packing Case
DHG2006
8
Bag
PHL1004
NSP
9
Label
VRW1629
Mark No.
Description
Part No.
PACKING PARTS LIST