ORDER NO.
PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan
PIONEER ELECTRONICS SERVICE, INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Allexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2000
c
RRV2373
DVD-R100
1. SAFETY INFORMATION ....................................... 2
2. CONTRAST OF MISCELLANEOUS PARTS .......... 4
3. EXPLODED VIEWS AND PARTS LIST ................. 5
4. SCHEMATIC DIAGRAM ...................................... 12
5. PCB CONNECTION DIAGRAM ........................... 14
CONTENTS
T ZZY NOV. 2000 Printed in Japan
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
DVD-R DRIVE UNIT
Remarks
Type
Model
DVD-R100
Power Requirement
ZUCYV/WL
O
DC Power supply from other system
NECESSARY INFORMATION FOR DHHS RULES
MARKED ON THE TOP COVER BELOW:
CAUTION LASER RADIATION WHEN OPEN.
DO NOT STARE INTO BEAM
¶ This service manual should be used together with the following manual(s):
Model No.
Order No.
Remarks
DVD-R7211/ZUCYV/WL
RRV2372
¶ Parts of the exploded views are all mentioned in this manual.
¶ The electrical parts are mentioned by contrast table in this manual.
6. ADJUSTMENT ..................................................... 15
7. GENERAL INFORMATION .................................. 16
7.1 DISASSEMBLY ............................................. 16
7.2 AGING MODE ............................................. 21
· Pull out the power cord because the power supply of a main body and connected peripheral
equipment is turned off without fail when this machine is maintained, and there is danger of
the electric shock etc.
DVD-R100
2
1. SAFETY INFORMATION
This service manual is intended for qualified service technicians; it is not meant for the casual
do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been
trained to properly and safely repair complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may
void the warranty. If you are not qualified to perform the repair of this product properly and safely, you
should not risk trying to do so and refer the repair to a qualified service technician.
WARNING
This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to cause
cancer, birth defects or other reproductive harm.
Health & Safety Code Section 25249.6 Proposition 65
VARO!
AVATTAESSA
JA
SUOJALUKITUS
OHITETTAESSA
OLET
ALTTIINA
NÄKYMÄTTÖMÄLLE
LASERSÄTEIYLLE.
ÄLÄ KATSO SÄTEESEEN.
ADVARSEL :
USYNLIG LASERSTRÅLING VED ÅBNING
NÅR SIKKERHED SAFBRYDERE ER UDE AF
FUNKTION.
UNDGÅ
UDSÆTTELSE
FOR
STRÅLING.
VARNING!
OSYNLIG LASERSTRÅLNING NÄR DENNA
DEL
ÄR
ÖPPNAD
OCH
SPÄRREN
ÄR URKOPPLAD. BETRAKTA EJ STRÅLEN.
WARNING!
DEVICE INCLUDES LASER DIODE WHICH
EMITS INVISIBLE INFRARED RADIATION
WHICH IS DANGEROUS TO EYES. THERE IS
A WARNING SIGN ACCORDING TO PICTURE
1 INSIDE THE DEVICE CLOSE TO THE LASER
DIODE.
IMPORTANT
THIS PIONNER APPARATUS CONTAINS
LASER OF CLASS 1.
SERVICING OPERATION OF THE APPARATUS
SHOULD BE DONE BY A SPECIALLY
INSTRUCTED PERSON.
LASER
kuva 1
Lasersateilyn
varoitusmerkki
LASER
Picture 1
Warning sign for
laser radiation
LASER DIODE CHARACTERISTICS
MAXIMUM OUTPUT POWER : 35 mw
WAVELENGTH : 658 nm
DVD-R100
3
1. The ON/OFF(ON:low level,OFF:high level) status of the
CLAMP signals for detcting the loading state are detected
by the drive CPUs, and the design prevents laser diode
oscillation when the CLAMP signal turns OFF.
In normal operation, if no disc is clamped, the laser diode
oscillation is disabled.
However, the interlock does not always operate in the test
mode.
*
2. When the cover is opened, close viewing of the objective
lens with the naked eye will cause exposure to a Class 3A
laser beam.
Additional Laser Caution
* Refer to pages 50 in the service manual RRV2372.
7LABEL CHECK
DRW1946
DAL1143
DVD-R100
4
2. CONTRAST OF MISCELLANEOUS PARTS
CONTRAST OF PCB ASSEMBLIES
DVD-R100/ZUCYV/WL and DVD-R7211/ZUCYV/WL are constructed the same except for the following :
PCB
ASSEMBLIES
NSP
WDIF ASSY
DWM2118
Not used
P7- 2
WIFB ASSY
DWX2112
DWX2117
*1
P7- 3
ID SB ASSY
DWS1297
Not used
Part No.
DVD-R7211/
ZUCYV/WL
Ref. No.
Symbol and Description
Remarks
Mark
DVD-R100/
ZUCYV/WL
*1: For WIFB ASSY, Refer to "PCB PARTS LIST, 4. SCHEMATIC DIAGRAM" and "PCB CONNECTION DIAGRAM".
Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List.
The
mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Screws adjacent to
mark on product are used for disassembly.
Reference Nos. indicate the pages and Nos. in the service manual for the base model.
NOTES:
When ordering resistors, first convert resistance values into code form as shown in the following examples.
Ex.1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47k ohm (tolerance is shown by J=5%,
and K=10%).
Ex.2 When there are 3 effective digits (such as in high precision metal film resistors).
561
473
R50
1R0
5621
560
47k
0.5
1
RD1/4PU
J
RD1/4PU
J
RN2H
K
RS1P
K
56 x 101
47 x 103
R50
1R0
561
473
5.62k
RN1/4PC
F
562 x 101
5621
WIFB ASSY
SEMICONDUCTORS
Q501
2SA933S
D501, D502
1SS133
D503
11EQS06
SWITCHES AND RELAYS
RY501
DSR1017
S503
DSX-104
S502
DSX1044
S501
DSX1046
CAPACITORS
C502
CEJQ470M25
C503, C504
CKPUYF104Z50
C501
CKPUYF223Z25
PCB PARTS LIST
Parts of the exploded views are all mentioned in this manual, Refer to "EXPLODED VIEWS
AND PARTSLIST".
Mark No.
Description
Part No.
RESISTORS
All Resistors
RD1/4PU
J
OTHERS
CN503
CONNECTOR 2P
S2B-PH-K-S
CN504
CONNECTOR 3P
S3B-PH-K-S
CN501
CONNECTOR 4P
S4B-PH-K-S
CN506
CONNECTOR 9P
S9B-PH-K-S
PCB BINDER
DEF1015
EARTH METAL FITTING
VNF-091
Mark No.
Description
Part No.
F
A
DVD-R100
5
3. EXPLODED VIEWS AND PARTS LIST
3.1 PACKING
NSP
1
Warranty Card
ARY1093
2
Operating Instructions
DRC1146
(English/ French/ German/ Japanese)
NSP
3
Polyethylene Bag
Z21-010
(100x 230x 0.018)
NSP
4
Polyethylene Bag
Z21-038
(230x 340x 0.03)
5
Pad
DHA1503
6
Pad
DHA1504
7
Packing Case
DHG2074
8
Bag
PHL1004
NSP
9
Label
VRW1629
10
SCSI Cable
DDC1006
11
Screw
BBZ30P080FZK
12
Function SW Label
DRW2021
NSP
13
Polyethylene Bag (50x 70x 0.03) Z21-002
Mark No.
Description
Part No.
PACKING PARTS LIST
4
10
2
11
12
13
1
3
7
6
5
8
9