· BASIC TAPE MECHANISM: CDS-522AV
· TYPE: YZ
STEREO CAR
CASSETTE RECEIVER
CT-FR929M
S/M Code No
. 09-993-408-5R1
REVISION PUBLISHING
This Service Manual is the "Revision Publishing" and replaces "Simple Manual"
(S/M Code No. 09-993-408-5T1).
2
SPECIFICATIONS
<FM RADIO SECTION>
Frequency Range:
87.5 MHz to 108 MHz
(50 kHz step)
Usable Sensitivity:
12.7 dBf
50 dB Quieting Sensitivity:
17.2 dBf
IF Rejection:
80 dB
Frequency Response:
30 Hz to 15,000 Hz
S/N Ratio:
63 dB
Stereo Separation:
35 dB at 1 kHz
Alternate Channel Selectivity:
70 dB
Capture Ratio:
3 dB
<AM RADIO SECTION>
<MW>
Frequency Range:
531 kHz to 1,602 kHz
(9 kHz step)
Usable Sensitivity:
30 µV (30 dB)
<LW>
Frequency Range:
144 kHz - 288 kHz
(1 kHz/9 kHz steps)
Usable Sensitivity:
30 µV (30 dB)
<TAPE SECTION>
Tape Speed:
4.8 cm/sec. (17/
8 ips)
S/N Ratio (normal):
50 dB
S/N Ratio (metal) :
Dolby NR off 54 dB
Dolby NR on 64 dB
Frequency Response (normal): 40 Hz - 14,000 Hz
(metal):
40 Hz - 16,000 Hz
Stereo Separation:
40 dB
FF/REW Time:
95 sec. (C-60)
<
AUDIO SECTION>
Max. Power Output:
40 W x 4 channels
<CD/MD IN input>
Input sensitivity (load impedance)
CD/MD IN:
500 mV (10 k
)
<GENERAL>
Power-supply Voltage:
14.4V (11 to 16 V allowable),
DC, negative ground
Load impedance:
4
Tone control:
Bass ±10 dB at 100 Hz
Treble ±10 dB at 10 kHz
Pre-amp Output Voltage (load impedance):
2.2 V (10 k
)
Installation size:
182 x 53 x 155 mm
(W x H x D)
(71/
4 x 2
1/
8 x 6
1/
8 in.)
Design and specifications are subject to change without notice.
Dolby noise reduction manufactured under license from Dolby
Laboratories Licensing Corporation.
"DOLBY" , and the double-D symbol
are trademarks of Dolby
Laboratories Licensing Corporation.
REF. NO
PART NO.
KANRI
DESCRIPTION
NO.
REF. NO
PART NO.
KANRI
DESCRIPTION
NO.
ACCESSORIES LIST
1
8Z-KT1-901-010
IB,YZ(9L) FR929M
1
8Z-KY1-904-010
IB,Y(3L,GIP CK) SW1-A
2
8Z-KT1-902-010
IB,INST,YZ (6L)FR929M
2
8Z-KT1-903-010
IB,INST,YZ (CZ-PO-H)FR929M
3
86-KT1-237-010
HLDR,REAR MTG
4
87-B10-141-010
NUT,5 TYPE-2
5
87-B10-143-010
UT1+5-15 W/O SLOT
6
87-B10-144-010
W,5.2-10-0.5
7
87-B10-145-010
W-SPR,5.3-8.5-1.5
8
88-KT1-247-010
S-SCREW,HEXAGON
9
8Z-KT1-030-010
CASE,DFP -T
10
8Z-KT1-231-010
HLDR,HALF -T
11
8Z-KT1-232-010
KEY,REMOVE -T
12
8Z-KT1-251-010
S-SCREW,5*6 TH+ TAPPING ST
13
88-KT1-250-010
S-SCREW,THIN HEAD+2.6-4 BLK
14
88-KC4-053-010
HLDR,BELT HRC
15
88-KC4-057-010
BELT, HRC
16
88-KC4-254-010
PLATE,NUT M3
17
88-KC4-255-010
S-SCREW,HEX-SOC+3-3.5 BLK
18
88-KC4-257-010
KEY,HEXAGON WRENCH
3
REF. NO
PART NO.
KANRI
DESCRIPTION
NO.
REF. NO
PART NO.
KANRI
DESCRIPTION
NO.
ELECTRICAL MAIN PARTS LIST
IC
88-KT1-607-080
C-IC,SAA6579T
87-A20-233-010
C-IC,HA12192F
88-KT1-604-010
IC,TA7291P
8Z-KT1-622-010
C-IC,LC75374E
87-A20-876-010
IC,HA13158
88-KT1-606-080
IC,PST994D
88-KTD-604-010
IC,BA09T
87-A21-267-010
C-IC,UPD178018AGC-527-3B9
87-002-689-080
IC,NJM2072M
8Z-KT1-623-010
C-IC,UPD16432B
87-A90-951-010
RCR UNIT,SBX1971-52
TRANSISTOR
89-324-122-080
TR,2SC2412K(R)
87-A30-289-040
C-TR,2SA1037AK(R)
87-A30-288-040
C-TR,DTC114YKA
87-A30-287-040
C-TR,DTC114TKA
87-A30-293-010
TR,KTC2804(Y)
87-A30-295-010
TR,KRA226M
87-A30-283-040
C-TR,DTA114YKA
87-A30-281-040
C-TR,DTC363TK
87-A30-282-040
C-TR,DTA114TKA
87-A30-290-010
TR,KTA1658(Y)
87-A30-291-010
TR,KTC4369(Y)
87-A30-292-010
TR,KTC3205(Y)
87-A30-294-040
C-TR,DTB123YK
DIODE
87-020-331-080
CHIP-DIODE,DAN202K
87-070-334-080
ZENER,MTZJ10B
87-017-932-080
ZENER,MTZJ6.2B
87-017-931-080
ZENER,MTZJ5.6B
87-001-783-080
DIODE,1N4002
87-A40-650-080
ZENER,MTZJ6.8A
87-070-136-080
ZENER,MTZJ5.1B
87-017-933-080
ZENER,MTZJ10D
87-A40-624-080
ZENER,MTZJ10A
87-A40-648-080
ZENER,MTZJ8.2A
87-A40-654-010
DIODE,DSA17B
87-020-585-080
CHIP-ZENER,02CZ6.2Y
MAIN C.B
C101
87-010-178-080
CHIP CAP 1000P
C102
87-010-186-080
CAP,CHIP 4700P
C103
87-010-490-040
CAP, ELECT 0.1-50
C104
87-010-197-080
CAP, CHIP 0.01 DM
C105
87-010-495-040
CAP,E 2.2-50 GAS
C106
87-010-198-080
CAP, CHIP 0.022
C107
87-010-552-040
CAP,E 22-16 GAS
C108
87-010-322-080
C-CAP,S 100P-50 CH
C109
87-010-553-040
CAP,E 47-16 GAS
C110
87-010-553-040
CAP,E 47-16 GAS
C111
87-010-197-080
CAP, CHIP 0.01 DM
C112
87-010-178-080
CHIP CAP 1000P
C114
87-010-178-080
CHIP CAP 1000P
C115
87-010-196-080
CHIP CAPACITOR,0.1-25
C116
87-010-178-080
CHIP CAP 1000P
C117
87-010-085-080
CHIP CAP 3900P
C119
87-010-196-080
CHIP CAPACITOR,0.1-25
C121
87-010-213-080
C-CAP,S 0.015-50 B
C122
87-010-213-080
C-CAP,S 0.015-50 B
C123
87-010-197-080
CAP, CHIP 0.01 DM
C124
87-010-196-080
CHIP CAPACITOR,0.1-25
C125
87-010-178-080
CHIP CAP 1000P
C126
87-010-178-080
CHIP CAP 1000P
C131
87-010-196-080
CHIP CAPACITOR,0.1-25
C132
87-010-198-080
CAP, CHIP 0.022
C133
87-016-459-040
CAP,E 470-10 SMG
C141
87-010-498-040
CAP,E 10-16 GAS
C142
87-010-498-040
CAP,E 10-16 GAS
C143
87-010-182-080
C-CAP,S 2200P-50 B
C144
87-010-182-080
C-CAP,S 2200P-50 B
C147
87-010-494-040
CAP,E 1-50 GAS
C148
87-010-494-040
CAP,E 1-50 GAS
C151
87-012-149-080
C-CAP,S 30P-50 CH
C152
87-010-315-080
C-CAP,S 27P-50 CH
C153
87-010-495-040
CAP,E 2.2-50 GAS
C154
87-012-157-080
C-CAP,S 330P-50 CH
C155
87-010-175-080
CAP 560P
C156
87-010-196-080
CHIP CAPACITOR,0.1-25
C201
87-010-178-080
CHIP CAP 1000P
C202
87-010-178-080
CHIP CAP 1000P
C203
87-010-197-080
CAP, CHIP 0.01 DM
C204
87-010-197-080
CAP, CHIP 0.01 DM
C205
87-010-196-080
CHIP CAPACITOR,0.1-25
C206
87-010-196-080
CHIP CAPACITOR,0.1-25
C207
87-010-493-040
CAP,E 0.47-50
C208
87-010-493-040
CAP,E 0.47-50
C209
87-010-196-080
CHIP CAPACITOR,0.1-25
C210
87-010-196-080
CHIP CAPACITOR,0.1-25
C211
87-010-494-040
CAP,E 1-50 GAS
C212
87-010-494-040
CAP,E 1-50 GAS
C221
87-010-492-040
CAP,E 0.33-50 GAS
C222
87-010-197-080
CAP, CHIP 0.01 DM
C223
87-010-197-080
CAP, CHIP 0.01 DM
C224
87-010-494-040
CAP,E 1-50 GAS
C225
87-010-494-040
CAP,E 1-50 GAS
C226
87-010-555-040
CAP,E 100-10 GAS
C227
87-010-196-080
CHIP CAPACITOR,0.1-25
C251
87-010-196-080
CHIP CAPACITOR,0.1-25
C252
87-A10-924-040
CAP,E 47-16 BP SME
C253
87-010-497-040
CAP,E 4.7-35 GAS
C254
87-010-553-040
CAP,E 47-16 GAS
C255
87-010-553-040
CAP,E 47-16 GAS
C301
87-010-498-040
CAP,E 10-16 GAS
C302
87-010-498-040
CAP,E 10-16 GAS
C303
87-010-494-040
CAP,E 1-50 GAS
C304
87-010-494-040
CAP,E 1-50 GAS
C305
87-010-184-080
CHIP CAPACITOR 3300P(K)
C306
87-010-184-080
CHIP CAPACITOR 3300P(K)
C307
87-010-198-080
CAP, CHIP 0.022
C308
87-010-198-080
CAP, CHIP 0.022
C309
87-010-498-040
CAP,E 10-16 GAS
C310
87-010-498-040
CAP,E 10-16 GAS
C311
87-A11-177-080
C-CAP,S 0.15-16 K B
C312
87-A11-177-080
C-CAP,S 0.15-16 K B
C313
87-A11-177-080
C-CAP,S 0.15-16 K B
C314
87-A11-177-080
C-CAP,S 0.15-16 K B
C315
87-010-498-040
CAP,E 10-16 GAS
C316
87-010-498-040
CAP,E 10-16 GAS
C321
87-010-196-080
CHIP CAPACITOR,0.1-25
C322
87-010-555-040
CAP,E 100-10 GAS
C323
87-010-196-080
CHIP CAPACITOR,0.1-25
C324
87-010-498-040
CAP,E 10-16 GAS
C351
87-010-498-040
CAP,E 10-16 GAS
C352
87-010-498-040
CAP,E 10-16 GAS
C353
87-010-498-040
CAP,E 10-16 GAS
C354
87-010-498-040
CAP,E 10-16 GAS
C355
87-010-491-040
CAP,E 0.22-50 GAS
C356
87-010-491-040
CAP,E 0.22-50 GAS
C365
87-010-178-080
CHIP CAP 1000P
C366
87-010-178-080
CHIP CAP 1000P
C367
87-010-178-080
CHIP CAP 1000P
C368
87-010-178-080
CHIP CAP 1000P
C381
87-010-196-080
CHIP CAPACITOR,0.1-25
4
REF. NO
PART NO.
KANRI
DESCRIPTION
NO.
REF. NO
PART NO.
KANRI
DESCRIPTION
NO.
C401
87-010-494-040
CAP,E 1-50 GAS
C402
87-010-494-040
CAP,E 1-50 GAS
C451
87-010-805-080
CAP, S 1-16
C452
87-010-805-080
CAP, S 1-16
C453
87-010-805-080
CAP, S 1-16
C454
87-010-805-080
CAP, S 1-16
C455
87-012-140-080
CAP 470P
C456
87-012-140-080
CAP 470P
C457
87-012-140-080
CAP 470P
C458
87-012-140-080
CAP 470P
C481
87-010-805-080
CAP, S 1-16
C482
87-010-805-080
CAP, S 1-16
C483
87-010-805-080
CAP, S 1-16
C484
87-010-805-080
CAP, S 1-16
C501
87-010-322-080
C-CAP,S 100P-50 CH
C502
87-010-322-080
C-CAP,S 100P-50 CH
C503
87-010-322-080
C-CAP,S 100P-50 CH
C504
87-010-322-080
C-CAP,S 100P-50 CH
C505
87-010-322-080
C-CAP,S 100P-50 CH
C506
87-010-322-080
C-CAP,S 100P-50 CH
C507
87-010-322-080
C-CAP,S 100P-50 CH
C508
87-010-322-080
C-CAP,S 100P-50 CH
C511
8Z-KT1-633-090
CAP,E 3300U-16 PW
C512
87-010-196-080
CHIP CAPACITOR,0.1-25
C513
87-010-498-040
CAP,E 10-16 GAS
C515
87-010-182-080
C-CAP,S 2200P-50 B
C516
87-010-196-080
C-CAP,S 0.47
C551
87-010-494-040
CAP,E 1-50 GAS
C590
87-012-349-080
C-CAP,S 1000P-50 CH
C601
87-010-935-040
CAP,E 220-16 M VR
C611
87-010-198-080
CAP, CHIP 0.022
C612
87-016-459-040
CAP,E 470-10 SMG
C621
87-010-198-080
CAP, CHIP 0.022
C622
87-010-555-040
CAP,E 100-10 GAS
C631
87-010-198-080
CAP, CHIP 0.022
C632
87-016-039-090
CAP,DL 0.022F-5.5 Z 70 FM
C633
87-010-198-080
CAP, CHIP 0.022
C634
87-010-198-080
CAP, CHIP 0.022
C635
87-010-553-040
CAP,E 47-16 GAS
C641
87-010-196-080
CHIP CAPACITOR,0.1-25
C642
87-010-196-080
CHIP CAPACITOR,0.1-25
C651
87-A11-177-080
C-CAP,S 0.15-16 K B
C652
87-A11-177-080
C-CAP,S 0.15-16 K B
C653
87-016-459-040
CAP,E 470-10 SMG
C661
87-010-198-080
CAP, CHIP 0.022
C662
87-010-553-040
CAP,E 47-16 GAS
C701
87-010-314-080
C-CAP,S 22P-50V
C702
87-010-315-080
C-CAP,S 27P-50 CH
C703
87-010-196-080
CHIP CAPACITOR,0.1-25
C704
87-010-196-080
CHIP CAPACITOR,0.1-25
C705
87-010-490-040
CAP, ELECT 0.1-50
C706
87-010-178-080
CHIP CAP 1000P
C707
87-010-178-080
CHIP CAP 1000P
C751
87-010-178-080
CHIP CAP 1000P
C752
87-010-322-080
C-CAP,S 100P-50 CH
C753
87-010-322-080
C-CAP,S 100P-50 CH
C754
87-010-197-080
CAP, CHIP 0.01 DM
C801
87-010-553-040
CAP,E 47-16 GAS
C802
87-010-555-040
CAP,E 100-10 GAS
C803
87-010-497-040
CAP,E 4.7-35 GAS
C804
87-010-495-040
CAP,E 2.2-50 GAS
C805
87-010-194-080
CAP, CHIP 0.047
C806
87-010-497-040
CAP,E 4.7-35 GAS
C807
87-010-555-040
CAP,E 100-10 GAS
C861
87-010-494-040
CAP,E 1-50 GAS
C862
87-010-494-040
CAP,E 1-50 GAS
C881
87-010-196-080
CHIP CAPACITOR,0.1-25
C882
87-010-182-080
C-CAP,S 2200P-50 B
C883
87-010-182-080
C-CAP,S 2200P-50 B
C884
87-010-182-080
C-CAP,S 2200P-50 B
CNA251
8Z-KT1-634-010
CONN ASSY,10P DECK-1
CNA252
8Z-KT1-635-010
CONN ASSY,5P DECK-2
CNA852
8Z-KT1-645-010
CONN ASSY,11P DFP-2
CNA853
8Z-KT1-644-010
CONN ASSY,6P DFP-1
CNA881
8Z-KT1-620-010
CONN ASSY,8P ISO-BLACK
CNA881
8Z-KT1-621-010
CONN ASSY,8P ISO-WHITE
D702
87-027-262-010
LEDE,TLR-124(RED)
J101
8Z-KT1-614-010
ANT,AW-002
J401
8Z-KT1-618-010
JACK,DIN 13 P TCS5116
J451
88-KTA-604-010
JACK,PIN 4P V-TYPE
L101
87-003-143-080
COIL 4.7 UH
L102
8Z-KT1-619-010
COIL,68MH K7-D
L151
87-003-147-080
COIL, 22UH
L631
87-003-149-080
COIL,47UH
L881
8Z-KT1-615-010
FLTR,AMORPHOUS -CHOKE
MIC801
8Z-KT1-643-090
MIC,EMC KUC2123-040245DB
PL701
8Z-KT1-641-010
LAMP,T-3
R605
88-148-102-080
C-RES, 1K-1/2W J
SFR101
87-024-437-080
SFR100K,RH063EC
SFR201
87-024-433-080
SFR,10K RH063EC
SFR202
87-024-433-080
SFR,10K RH063EC
SW701
87-A91-155-010
SW,TACT SKHHLQ
SW703
87-036-109-010
PUSH SWITCH
TU101
8Z-KT1-631-010
TU UNIT, FAE347-A02
X151
87-A70-091-010
VIB,XTAL 4.332MHZ CSA-309
X701
87-A70-175-010
VIB,XTAL 4.5MHZ AT-49
FRONT C.B
C901
87-010-196-080
CHIP CAPACITOR,0.1-25
C902
87-010-196-080
CHIP CAPACITOR,0.1-25
C903
87-010-805-080
CAP, S 1-16
C904
87-010-805-080
CAP, S 1-16
C905
87-010-322-080
C-CAP,S 100P-50 CH
C906
87-010-322-080
C-CAP,S 100P-50 CH
C907
87-010-322-080
C-CAP,S 100P-50 CH
C908
87-010-322-080
C-CAP,S 100P-50 CH
C909
87-010-322-080
C-CAP,S 100P-50 CH
CON901
8Z-KT1-612-010
CONN,16P CAM-C73
D921
87-A40-621-040
C-LED,SEC2484C GR/AMB
D922
87-A40-621-040
C-LED,SEC2484C GR/AMB
D923
87-A40-621-040
C-LED,SEC2484C GR/AMB
D924
87-A40-621-040
C-LED,SEC2484C GR/AMB
D925
87-A40-621-040
C-LED,SEC2484C GR/AMB
D926
87-A40-621-040
C-LED,SEC2484C GR/AMB
D927
87-A40-621-040
C-LED,SEC2484C GR/AMB
D928
87-A40-621-040
C-LED,SEC2484C GR/AMB
D929
87-A40-621-040
C-LED,SEC2484C GR/AMB
D930
87-A40-621-040
C-LED,SEC2484C GR/AMB
D931
87-A40-621-040
C-LED,SEC2484C GR/AMB
D932
87-A40-621-040
C-LED,SEC2484C GR/AMB
D933
87-A40-621-040
C-LED,SEC2484C GR/AMB
D934
87-A40-621-040
C-LED,SEC2484C GR/AMB
D935
87-A40-621-040
C-LED,SEC2484C GR/AMB
D936
87-A40-621-040
C-LED,SEC2484C GR/AMB
D937
87-A40-621-040
C-LED,SEC2484C GR/AMB
D938
87-A40-621-040
C-LED,SEC2484C GR/AMB
D939
87-A40-621-040
C-LED,SEC2484C GR/AMB
D940
87-A40-621-040
C-LED,SEC2484C GR/AMB
D941
87-A40-621-040
C-LED,SEC2484C GR/AMB
L901
87-005-902-080
C-COIL,S 4.7UH K LK2125
L902
87-005-902-080
C-COIL,S 4.7UH K LK2125
L903
87-005-902-080
C-COIL,S 4.7UH K LK2125
LCD901
8Z-KT1-607-010
LCD,ZKT-1
PL901
8Z-KT1-651-010
LAMP,9V-85MA
PL902
8Z-KT1-651-010
LAMP,9V-85MA
SW901
87-A90-001-080
C-SW,TACT SKQMAL
SW902
87-A90-001-080
C-SW,TACT SKQMAL
SW903
87-A90-001-080
C-SW,TACT SKQMAL
5
88
A
Resistor Code
Chip Resistor Part Coding
Figure
Value of resistor
Chip resistor
Wattage
Type
Tolerance
1/16W
1/10W
1/8W
1608
2125
3216
5%
5%
5%
CJ
CJ
CJ
Form
LW
t
1.6
0.8
0.45
2
1.25
0.45
3.2
1.6
108
118
128
: A
: A
CHIP RESISTOR PART CODE
0.55
Resistor Code
Dimensions (mm)
Symbol
1/16W
1005
5%
CJ
1.0
0.5
0.35
104
L
t
W
SW904
87-A90-001-080
C-SW,TACT SKQMAL
SW905
87-A90-001-080
C-SW,TACT SKQMAL
SW906
87-A91-159-010
SW,TACT SKHLAD
SW907
87-A90-001-080
C-SW,TACT SKQMAL
SW908
87-A90-001-080
C-SW,TACT SKQMAL
SW909
87-A90-001-080
C-SW,TACT SKQMAL
SW910
87-A91-159-010
SW,TACT SKHLAD
SW911
87-A90-001-080
C-SW,TACT SKQMAL
SW912
87-A90-001-080
C-SW,TACT SKQMAL
SW913
87-A91-159-010
SW,TACT SKHLAD
SW914
87-A90-001-080
C-SW,TACT SKQMAL
SW915
87-A90-001-080
C-SW,TACT SKQMAL
SW916
87-A90-001-080
C-SW,TACT SKQMAL
SW917
87-A90-001-080
C-SW,TACT SKQMAL
SW918
87-A90-001-080
C-SW,TACT SKQMAL
SW919
87-A91-159-010
SW,TACT SKHLAD
SW920
87-A90-001-080
C-SW,TACT SKQMAL
SW921
87-A91-159-010
SW,TACT SKHLAD
SW931
87-036-127-010
SLIDE SWITCH
SUB C.B
CON851
8Z-KT1-613-010
CONN,16P CAM-C74
CON853
87-009-411-010
CONN,6P ZH V
SW702
87-036-220-080
C-SW,T
JACK C.B
J901
87-A60-249-010
JACK,MOJ-B32
REEL C.B
M1
S1-003-670-570
MOTOR,SUB
SW1
S1-052-270-100
SW,LEAF(MSL-2)
SW2
S1-052-270-110
SW,LEAF(MLS-4)
HEAD C.B
M2
S1-052-270-180
MOTOR,SUB
PH1
SX-005-270-400
PHOTO COUPLER ASSY
SW3
S1-005-670-110
SW,SW-112
SW4
S1-003-670-071
SW,SLIDE(SLD-32-710S)
REF. NO
PART NO.
KANRI
DESCRIPTION
NO.
REF. NO
PART NO.
KANRI
DESCRIPTION
NO.