SERVICE MANUAL
DA
TA
RADIO RECEIVER
CR-AS22
S/M Code No. 09-023-457-6T1
SIMPLE
YZ(S)
· Replace this Service Manual with "Revision Publishing" when it is issued.
!
= ! SAFTY PARTS
C
= Components marked
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
UNIT-NAME
! C REF-NO PARTS-NO
PARTS-NAME
SUFFIX&MODEL
2
ELECTRICAL PARTS LIST
CR-AS22
YZBSC
X C
002
S8-055-330-532 CHIP C-CAP 33PF 50V +/-5% NPO
a
X C
003
S8-056-470-532 CAP MONO NPO 47PF 50V 10%(SMD
a
X C
004
S8-036-223-549 CHIP C-CAP 0.022UF B 16V +/-1
a
O C
005
87-016-299-080 CAP,E 10-10V
a
X C
006
S8-054-030-532 CHIP C.CAP 3PF 50V +/-0.25PF
a
X C
007
S8-055-180-532 CHIP C.CAP 18PF 50V +/-5% NPO
a
X C
008
S8-055-250-532 CHIP CAP NPO 25PF 50V +/-5% (
a
X C
009
S8-056-103-548 CAP MONO X7R 0.01UF 50V 10%(S
a
X C
010
S8-054-030-532 CHIP C.CAP 3PF 50V +/-0.25PF
a
O C
012
87-010-403-080 CAP,E 3.3-50V
a
X C
013
S8-056-103-548 CAP MONO X7R 0.01UF 50V 10%(S
a
O C
014
87-016-299-080 CAP,E 10-10V
a
O C
015
87-010-404-080 CAP,E 4.7UF-50V
a
O C
016
87-016-299-080 CAP,E 10-10V
a
X C
017
S6-257-223-200 CAP,M 0.022UF-50V
a
O C
018
87-010-400-080 CAP,E 0.47UF-50V
a
X C
020
S5-157-104-400 CAP,CER 0.1UF-50V
a
O C
021
87-010-221-080 CAP,E 470UF-10V
a
X C
022
S8-030-224-500 CHIP C CAP 0.22UF 16V +80% -2
a
O C
023
87-010-562-040 CAP,E 220UF-10V
a
CR-AS22
YZBSC
X C
025
S8-036-223-549 CHIP C-CAP 0.022UF B 16V +/-1
a
X C
026
S8-056-103-548 CAP MONO X7R 0.01UF 50V 10%(S
a
X C
028
S8-056-050-500 C-CAP 5P-50
a
O CF 001
S1-910-010-300 CER,FIL 450K
a
O CF 002
87-008-462-010 CER,FIL SFT10.7MS23H-A
a
O CF 003
S2-310-010-100 DISCRMINATOR FILTER 10.7MHZ
a
O D
001
82-135-799-010 DIODE,1N4148
a
O D
002
82-135-799-010 DIODE,1N4148
a
S IC 001
S2-522-426-000 IC KA22426D
a
O J
001
S1-210-015-301 JACK,HP 3.5MM
a
X JMP001
S0-691-200-000 BARE WIRE 12MM
a
X JMP002
S0-691-600-000 BARE WIRE 16MM
a
X JMP003
S0-691-200-000 BARE WIRE 12MM
a
X JMP004
S0-690-600-000 BARE WIRE 6MM
a
X JMP007
S0-692-200-000 BARE WIRE DIA0.6MM BRIDGE LEN
a
X JMP009
S0-690-600-000 BARE WIRE 6MM
a
O L
001
S1-110-013-900 COIL,AIR FM 3-5.5-0.5
a
X L
002
S0-200-050-000 SPONGE 8-12
a
X L
002
S1-110-016-301 COIL,FM SPR 3.5-3.5
a
X L
003
S0-200-050-000 SPONGE 8-12
a
CR-AS22
YZBSC
X L
003
S1-110-013-100 COIL,FM 3-5.5-0.5
a
O L
004
87-003-108-010 COIL,0.68UH
a
O L
005
S1-110-013-200 COIL,OSC AM 8441A 7ZO-93100
a
O L
006
S2-810-010-600 COIL,1.5UH
a
X L
006
S6-125-104-500 C-RES,100K-1/10W
a
O LED001
S5-570-100-100 LED,3.0MM(RED)
a
O PVC001
S2-010-011-001 AM/FM PVC 16MM JF444WAB82-A1.
a
X R
001
S6-125-183-500 CHIP RESISTOR 18K OHM 1/10W +
a
X R
002
S6-125-122-500 CHIP RESISTOR 1.2K OHM 1/10W
a
X R
003
S6-125-331-500 C-RES,330-1/10W
a
X R
004
S6-125-102-500 C-RES,1K-1/10W
a
X R
007
S5-015-270-100 RES,27-1/8W
a
X R
008
S6-125-152-500 CHIP RESISTOR 1.5K OHM 1/10W
a
X R
009
S6-125-221-500 CHIP RESISTOR 220 OHM 1/10W +
a
X R
010
S6-125-472-500 C-RES,4.7K-1/10W
a
X R
011
S6-125-151-500 CHIP RESISTOR 150 OHM 1/10W +
a
X R
012
S6-125-102-500 C-RES,1K-1/10W
a
X R
013
S6-125-000-500 CHIP RESISTOR O OHM 1/10W +/-
a
O SW 001
87-A91-152-010 SW,SLIDE 1P2T
a
O T
002
S1-007-000-600 IFT,AM 7.8-7.8-12.5MM
a
CR-AS22
YZBSC
O VR 001
S2-110-010-203 VR RTRY B50K-A
a
X W
001
S2-010-603-100 UL STRANDED 60MM(BRN)
a
X W
002
S2-040-603-500 UL STRANDED 60MM(YEL)
a
X W
003
S2-001-203-500 UL-1007 STRANDED AWG#26 120MM
a
X W
004
S2-020-603-200 UL-1007 STRANDED AWG#26 60MM
a
!
= ! SAFTY PARTS
C
= Components marked
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
UNIT-NAME
! C REF-NO PARTS-NO
PARTS-NAME
SUFFIX&MODEL
3
MECHANICAL PARTS LIST
CR-AS22
YZBSC
O MC1001
S1-003-022-500 8C-RCJ-003-01 DOOR, BATT
a
O MC1002
S0-801-940-100 8C-RCJ-009-01 LENS, DIAL YZ
a
O MC1003
S0-201-980-100 8C-RCJ-011-01 CABI, REAR YZ/Y
a
O MC1004
S1-010-012-201 AM BAR ANTENNA SET 125:30T DI
a
O MC1005
S2-002-030-600 BATT CONTACT (-)
a
O MC1006
S1-102-140-001 FERRIC BAR HOLDER
a
O MC1007
S2-010-012-301 FM ROD ANT 5 SECTION
a
O MC1008
S1-001-021-200 FRONT CABINET
a
O MC1009
S0-504-080-000 KNOB, RTRY TUN
a
O MC1010
S0-504-060-000 KNOB, RTRY VOL
a
O MC1011
S0-504-070-000 KNOB, SL BAND
a
O MC1012
S1-103-400-000 LED SPACER
a
X MC1013
S3-018-010-100 MAIN PCB NS6732 T=1.2MM
a
O MC1014
87-261-073-410 PAN S-SCREW(B) M2.6-6
a
O MC1015
87-254-033-410 PAN-WASHER S-SCREW M2-4(T)
a
O MC1016
S4-402-060-000 PAN-WASHER(PHILIP),S-SCREW(T)
a
X MC1017
S0-401-090-000 PLATE BAT
a
O MC1018
S0-700-510-000 POINTER
a
O MC1019
S0-600-140-000 PVC ADAPTER
a
O MC1020
S1-010-032-500 SPKR,SLIM MYLAR 57MM 0.2W 4OH
a
CR-AS22
YZBSC
O MC1021
S0-401-080-000 TERIMAL CONTACT
a
O MC1022
S1-701-380-000 TUNING GEAR (PVC)
a
O MC1023
87-265-071-210 PAN M-SCREW M2.6-4
a
O MC1024
87-268-527-310 PAN M-SCREW M1.7-3
a
O MC1025
87-268-529-310 PAN M-SCREW M1.7-4
a
!
= ! SAFTY PARTS
C
= Components marked
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
UNIT-NAME
! C REF-NO PARTS-NO
PARTS-NAME
SUFFIX&MODEL
4
ACCESSORIES PARTS LIST
CR-AS22
YZBSC
O
001
S7-001-008-200 HAND STRAP
a
!
= ! SAFTY PARTS
C
= Components marked
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
UNIT-NAME
! C REF-NO PARTS-NO
PARTS-NAME
SUFFIX&MODEL
5
OTHERS PARTS LIST
CR-AS22
YZBSC
X
S8-810-010-200 EYELET 1.5-4
a
X
S8-810-011-000 EYELET,1.7-4.2
a