SERVICE MANUAL
DA
TA
STEREO CAR CD RECEIVER
CDC-Z107
YU
S/M Code No. 09-002-422-4R1
REVISION
· This Service Manual is the "Revision Publishing" and replaces "Simple Manual"
of CDC-Z107<YU>, (S/M Code No. 09-99B-422-4T1).
BASIC CD MECHANISM : TN-CCD1001-113J
SPECIFICATIONS
RADIO SECTION
(FM)
Frequency Range
87.5 MHz 108 MHz (100-kHz steps)
87.5 MHz 108 MHz (50-kHz steps)
Usable Sensitivity
12.7 dBf
50 dB Quieting Sensitivity 17.2 dBf
IF Rejection
80 dB
Frequency Response
30 Hz 15,000 Hz
S/N Ratio
63 dB
Stereo Separation
35 dB at 1 kHz
Alternate Channel Selectivity
70 dB
Capture Ratio
3 dB
(AM)
Frequency Range
530 kHz 1,710 kHz (10-kHz steps)
531 kHz 1,602 kHz (9-kHz steps)
Usable Sensitivity
30
µV (30 dB)
Set the frequency increment for your area using the switch on the
bottom of the unit.
(The switch is set at the factory to the 10k position [for the U.S.A.])
CD SECTION
Frequency Response
17 Hz 20 kHz +0/3 dB
Dynamic Range
More than 80 dB
Channel Separation
More than 65 dB
S/N Ratio
More than 85 dB
Wow/Flutter
Unmeasurable
AUDIO SECTION
Max. Power Output
45 W x 4 channels
TAPE/MD IN input
Input Sensitivity (load impedance)
TAPE/MD IN
500 mV (10 k
)
GENERAL
Power Supply Voltage
14.4 V (11 to 16 V allowable),
DC, negative ground
Load Impedance
4
Tone Control
Bass
±10 dB at 100 Hz
Treble
±10 dB at 10 kHz
Preamp Output Voltage (load impedance)
2.2 V (10 k
)
Installation Size
182 (W) x 53 (H) x 155 (D) mm
(71/
4 (W) x 2
1/
8 (H) x 6
1/
8 (D) inches)
· Design and specifications are subject to change without
notice.
ACCESSORIES / PACKAGE LIST
KANRI
REF. NO.
DESCRIPTION
PART NO.
1
8A-KC7-902-010
IB,INST,YU,YL (3L,P)
1
8A-KCH-901-010
IB,YU(3L) 107
2
87-B10-141-010
NUT,5 TYPE-2
3
87-B10-143-010
UT1+5-15 W/O SLOT
4
87-B10-144-010
W,5.2-10-0.5
5
87-B10-145-010
W-SPR,5.3-8.5-1.5
6
8Z-KC1-231-110
HLDR,HALF -C
7
8Z-KC1-232-010
KEY,REMOVE -C
8
8Z-KC1-235-010
HLDR,REAR MTG
9
8Z-KC1-244-010
S-SCREW,5*6 TH+ TAPPING ST
10
8Z-KC1-250-010
S-SCREW,HEXAGON
11
8Z-KT1-616-010
CONN ASSY,16P B52
- 2 -
Precaution to replace Optical block
(OPTIMA-720AIE)
Body or clothes electrostatic potential could
ruin laser diode in the optical block. Be sure
ground body and workbench, and use care
the clothes do not touch the diode.
1) After the connection, remove solder
shown in right figure.
- 3 -
CLASS 1
LASER PRODUCT
KLASSE 1
LASER PRODUKT
LUOKAN 1
LASER LAITE
KLASS 1
LASER APPARAT
This set employs laser. Therefore, be sure to follow carefully
the instructions below when servicing.
WARNING!!
WHEN SERVICING, DO NOT APPROACH THE LASER
EXIT WITH THE EYE TOO CLOSELY. IN CASE IT IS
NECESSARY TO CONFIRM LASER BEAM EMISSION.
BE SURE TO OBSERVE FROM A DISTANCE OF MORE
THAN 30cm FROM THE SURFACE OF THE OBJEC-
TIVE LENS ON THE OPTICAL PICK-UP BLOCK.
s Caution: Invisible laser radiation when
open and interlocks defeated avoid
exposure to beam.
s Advarsel: Usynlig laserståling ved åbning,
når sikkerhedsafbrydere er ude af funktion.
Undgå udsættelse for stråling.
VAROITUS!
Laiteen Käyttäminen muulla kuin tässä käyttöohjeessa
mainitulla
tavalla
saataa
altistaa
käyt-täjän
turvallisuusluokan 1 ylittävälle näkymättömälle
lasersäteilylle.
VARNING!
Om apparaten används på annat sätt än vad som
specificeras i denna bruksanvising, kan användaren
utsättas för osynling laserstrålning, som överskrider
gränsen för laserklass 1.
PROTECTION OF EYES FROM LASER BEAM DURING SERVICING
CAUTION
Use of controls or adjustments or performance of proce-
dures other than those specified herin may result in
hazardous radiation exposure.
ATTENTION
L'utillisation de commandes, réglages ou procédures
autres que ceux spécifiés peut entraîner une dangereuse
exposition aux radiations.
ADVARSEL
Usynlig laserståling ved åbning, når sikkerhedsafbrydereer
ude af funktion. Undgå udsættelse for stråling.
This Compact Disc player is classified as a CLASS 1
LASER product.
The CLASS 1 LASER PRODUCT label is located on the
rear exterior.
PICK-UP ASSY
P.C.B
KANRI
NO.
REF. NO.
DESCRIPTION
PART NO.
KANRI
NO.
REF. NO.
DESCRIPTION
PART NO.
- 4 -
IC
87-A20-446-010
C-IC,LA9241ML
87-A21-319-010
C-IC,LC78622NE
87-A21-488-040
C-IC,LA6556
8Z-KT1-622-010
C-IC,LC75374E
87-A21-562-010
IC,LA4743B
88-KT1-606-080
IC,PST994D
87-A21-535-030
C-IC,LC72358N-9910
87-A21-489-030
C-IC,LC75853NW
TRANSISTOR
89-324-122-080
TR,2SC2412K
87-A30-289-040
C-TR,2SA1037AK(R)
87-A30-288-040
C-TR,DTC114YKA
87-A30-287-040
C-TR,DTC114TKA
87-026-235-080
CHIP-TR,DTC114EK
87-026-210-080
CHIP-TR,DTC144EK
87-A30-299-080
TR,2SB1326
87-A30-282-040
C-TR,DTA114TKA
87-A30-168-010
TR,2SB1566F
89-211-821-080
CHIP-TR 2SB1182Q
89-423-953-010
TR,2SD2395F
87-A30-301-080
TR,2SD1862
87-A30-449-040
C-TR,DTA123YKA
DIODE
87-A40-250-080
CHIP-DIODE,DAN217
87-001-783-080
DIODE,1N4002
87-020-331-080
C-DIODE,DAN202K
87-A40-624-080
ZENER,MTZJ10A
87-A40-523-080
ZENER,MTZJ9.1B
87-070-136-080
ZENER,MTZJ5.1B
87-017-932-080
ZENER,MTJ6.2B
87-A40-798-010
DIODE,1N5402 (3A/200V)
MAIN C.B
C101
87-010-178-080
CHIP CAP 1000P
C102
87-010-197-080
CAP, CHIP 0.01 DM
C103
87-010-495-040
CAP,E 2.2-50 GAS
C106
87-010-322-080
C-CAP,S 100P-50 CH
C107
87-010-552-040
CAP,E 22-16 GAS
C108
87-010-322-080
C-CAP,S 100P-50 CH
C109
87-010-553-040
CAP,E 47-16 GAS
C110
87-010-198-080
CAP, CHIP 0.022
C111
87-010-553-040
CAP,E 47-16 GAS
C112
87-010-185-080
C-CAP,S 3900P-50 B
C113
87-010-197-080
CAP, CHIP 0.01 DM
C114
87-010-197-080
CAP, CHIP 0.01 DM
C115
87-010-196-080
CHIP CAPACITOR,0.1-25
C116
87-010-196-080
CHIP CAPACITOR,0.1-25
C131
87-012-365-080
C-CAP,S 0.027-25VBK
C132
87-012-365-080
C-CAP,S 0.027-25VBK
C133
87-012-358-080
C-CAP,S 0.47-10 F Z
C134
87-012-358-080
C-CAP,S 0.47-10 F Z
C161
87-010-196-080
CHIP CAPACITOR,0.1-25
C171
87-010-197-080
CAP, CHIP 0.01 DM
C173
87-010-322-080
C-CAP,S 100P-50 J CH GRM
C201
87-010-553-040
CAP,E 47-16 GAS
C202
87-010-553-040
CAP,E 47-16 GAS
C203
87-010-178-080
CHIP CAP 1000P
C204
87-016-669-080
C-CAP,S 0.1-25 K B
C205
87-A11-606-080
C-CAP,S 0.22-25 K B
C206
87-010-492-040
CAP,E 0.33-50 GAS
C207
87-010-195-080
C-CAP,S 0.068-25 Z F C2012
C208
87-010-176-080
C-CAP,S 680P-50 J SL
C209
87-010-992-080
C-CAP,S 0.047-25 K B MK212
C210
87-016-669-080
C-CAP,S 0.1-25 K B
C211
87-010-498-040
CAP,E 10-16 M 5L SRE
C212
87-010-180-080
C-CER 1500P
C213
87-010-992-080
CAP, CHIP 0.047
C214
87-016-669-080
CHIP CAPACITOR,0.1-25
C215
87-010-178-080
CHIP CAP 1000P
C216
87-A11-606-080
C-CAP,S 0.22-25 K B
C217
87-016-669-080
CAP, CHIP 0.01 DM
C218
87-010-198-080
CAP, CHIP 0.022
C219
87-012-157-080
C-CAP,S 330P-50 CH
C220
87-010-184-080
CHIP CAPACITOR 3300P(K)
C221
87-010-322-080
C-CAP,S 100P-50 CH
C222
87-010-492-040
CAP,E 0.33-50 GAS
C223
87-010-067-040
CAP,E 0.1-50 5L
C224
87-010-553-040
CAP,E 47-16 GAS
C225
87-010-805-080
C-CAP,S 1-16 Z F
C226
87-010-497-040
CAP,E 4.7-35 GAS
C227
87-010-555-040
CAP,E 100-10 GAS
C228
87-016-669-080
CHIP CAPACITOR,0.1-25
C229
87-010-498-040
CAP,E 10-16 GAS
C230
87-016-669-080
CHIP CAPACITOR,0.1-25
C231
87-010-555-040
CAP,E 100-10 GAS
C232
87-016-669-080
CHIP CAPACITOR,0.1-25
C233
87-010-555-040
CAP,E 100-10 GAS
C234
87-010-193-080
CHIP CAPACITOR,0.033
C235
87-010-992-080
CAP, CHIP 0.047
C236
87-010-067-040
CAP,E 0.1-50 5L
C237
87-010-553-040
CAP,E 47-16 GAS
C238
87-010-197-080
CAP, CHIP 0.01 DM
C240
87-016-669-080
C-CAP,S 0.1-25 K B
C250
87-016-669-080
CHIP CAPACITOR,0.1-25
C251
87-010-555-040
CAP,E 100-10 GAS
C252
87-016-669-080
CHIP CAPACITOR,0.1-25
C253
87-016-669-080
CHIP CAPACITOR,0.1-25
C254
87-016-669-080
CHIP CAPACITOR,0.1-25
C256
87-010-186-080
CAP,CHIP 4700P
C258
87-010-150-080
C-CAP,S 6P-50 D CH
C259
87-010-316-080
C-CAP,S 33P-50 CH
C261
87-012-156-080
C-CAP,S 220P-50 CH
C262
87-016-669-080
CHIP CAPACITOR,0.1-25
C263
87-010-555-040
CAP,E 100-10 GAS
C264
87-010-555-040
CAP,E 100-10 GAS
C265
87-016-669-080
CHIP CAPACITOR,0.1-25
C266
87-016-669-080
CHIP CAPACITOR,0.1-25
C267
87-010-498-040
CAP,E 10-16 GAS
C268
87-010-498-040
CAP,E 10-16 GAS
C269
87-010-180-080
C-CER 1500P
C270
87-010-180-080
C-CER 1500P
C271
87-010-154-080
CAP CHIP 10P
C272
87-010-154-080
CAP CHIP 10P
C273
87-010-494-040
CAP,E 1-50 GAS
C274
87-010-494-040
CAP,E 1-50 GAS
C280
87-A10-189-040
CAP,E 220-10
C281
87-010-555-040
CAP,E 100-10 GAS
C282
87-016-669-080
CHIP CAPACITOR,0.1-25
C301
87-010-498-040
CAP,E 10-16 GAS
C302
87-010-498-040
CAP,E 10-16 GAS
C303
87-010-494-040
CAP,E 1-50 GAS
C304
87-010-494-040
CAP,E 1-50 GAS
C305
87-010-184-080
CHIP CAPACITOR 3300P(K)
C306
87-010-184-080
CHIP CAPACITOR 3300P(K)
C307
87-010-198-080
CAP, CHIP 0.022
C308
87-010-198-080
CAP, CHIP 0.022
C309
87-010-498-040
CAP,E 10-16 GAS
C310
87-010-498-040
CAP,E 10-16 GAS
C311
87-A11-177-080
C-CAP,S 0.15-16 K B
C312
87-A11-177-080
C-CAP,S 0.15-16 K B
C313
87-A11-177-080
C-CAP,S 0.15-16 K B
C314
87-A11-177-080
C-CAP,S 0.15-16 K B
C315
87-010-498-040
CAP,E 10-16 GAS
ELETRICAL MAIN PARTS LIST
KANRI
NO.
REF. NO.
DESCRIPTION
PART NO.
KANRI
NO.
REF. NO.
DESCRIPTION
PART NO.
- 5 -
C316
87-010-498-040
CAP,E 10-16 GAS
C321
87-010-196-080
CHIP CAPACITOR,0.1-25
C322
87-010-555-040
CAP,E 100-10 M 5L SRE
C323
87-010-196-080
CHIP CAPACITOR,0.1-25
C324
87-010-498-040
CAP,E 10-16 GAS
C351
87-010-494-040
CAP,E 1-50 GAS
C352
87-010-494-040
CAP,E 1-50 GAS
C353
87-010-494-040
CAP,E 1-50 GAS
C354
87-010-494-040
CAP,E 1-50 GAS
C361
87-012-358-080
C-CAP,S 0.47-10 F Z
C362
87-012-358-080
C-CAP,S 0.47-10 F Z
C363
87-012-358-080
C-CAP,S 0.47-10 F Z
C364
87-012-358-080
C-CAP,S 0.47-10 F Z
C365
87-010-175-080
CAP 560P
C366
87-010-175-080
CAP 560P
C367
87-010-175-080
CAP 560P
C368
87-010-175-080
CAP 560P
C453
87-010-498-040
CAP,E 10-16 GAS
C454
87-010-498-040
CAP,E 10-16 GAS
C457
87-012-140-080
CAP 470P
C458
87-012-140-080
CAP 470P
C461
87-005-902-080
C-COIL,S 4.7UH K LK2125
C511
8A-KC7-623-000
CAP,E 2200U-16 BT(125C)
C512
87-010-196-080
CHIP CAPACITOR,0.1-25
C513
87-010-196-080
CHIP CAPACITOR,0.1-25
C514
87-010-553-040
CAP,E 47-16 M 5L SRE
C515
87-010-494-040
CAP,E 1-50 GAS
C516
87-010-178-080
CHIP CAP 1000P
C517
87-010-178-080
CHIP CAP 1000P
C519
87-010-494-040
CAP,E 1-50 M 5L SRE
C551
87-010-553-040
CAP,E 47-16 GAS
C590
87-010-178-080
CHIP CAP 1000P
C611
87-010-553-040
CAP,E 47-16 GAS
C612
87-010-198-080
CAP, CHIP 0.022
C613
87-016-044-040
CAP,E 100-16 GAS
C621
87-010-553-040
CAP,E 47-16 GAS
C622
87-010-553-040
CAP,E 47-16 GAS
C641
87-010-196-080
CHIP CAPACITOR,0.1-25
C642
87-010-196-080
CHIP CAPACITOR,0.1-25
C671
87-010-198-080
CAP, CHIP 0.022
C672
87-010-555-040
CAP,E 100-10 GAS
C673
87-010-553-040
CAP,E 47-16 GAS
C674
87-010-198-080
CAP, CHIP 0.022
C681
87-010-553-040
CAP,E 47-16 GAS
C682
87-010-198-080
CAP, CHIP 0.022
C701
87-010-315-080
C-CAP,S 27P-50 CH
C702
87-010-314-080
C-CAP,S 22P-50V
C706
87-010-497-040
CAP,E 4.7-35 GAS
C711
87-010-322-080
C-CAP,S 100P-50 CH
C712
87-010-322-080
C-CAP,S 100P-50 CH
C761
87-010-555-040
CAP,E 100-10 GAS
C763
87-010-196-080
CHIP CAPACITOR,0.1-25
C771
87-012-156-080
C-CAP,S 220P-50 J CH GRM
C831
87-010-494-040
CAP,E 1-50 GAS
C832
87-010-494-040
CAP,E 1-50 GAS
C835
87-010-182-010
C-CAP,S 2200P-50 K B C2012
C836
87-010-182-010
C-CAP,S 2200P-50 K B C2012
C881
87-010-182-080
C-CAP,S 2200P-50 B
C882
87-010-182-080
C-CAP,S 2200P-50 B
C883
87-010-182-080
C-CAP,S 2200P-50 B
C884
87-010-182-080
C-CAP,S 2200P-50 B
CON201
87-A60-859-010
CONN,12P TKC-F12X-K1
CON202
87-A60-860-010
CONN,14P TKC-F14X-K1
CON881
8Z-KT1-611-010
CONN,16P CAM-B51
F881
8Z-KC1-621-010
FUSE,15A 32V
J101
8Z-KT1-614-010
ANT,AW-002
J451
87-A61-225-010
JACK,PIN 2P XR-401
L101
87-003-143-080
COIL 4.7 UH
L102
8Z-KT1-619-010
COIL,68MH K7-D
L671
87-003-149-080
COIL,47UH
L831
87-003-143-080
COIL,4.7UH K LAL02
L881
8Z-KT1-615-010
FLTR,AMORPHOUS -CHOKE
R241
87-022-371-080
C-RES,S 330K-1/10W F
R242
87-022-371-080
C-RES,S 330K-1/10W F
SW702
87-A91-152-010
SW,SL 1-1-2 SSSS212-11-A
TU101
8A-KC8-621-010
TU UNIT, FAE347-A12
X201
81-592-641-010
VIB,CER 16.93MHZ
X701
87-A70-175-010
VIB,XTAL 4.5MHZ AT-49
FRONT C.B
C901
87-010-805-080
CAP, S 1-16
C902
87-010-194-080
CAP, CHIP 0.047
C903
87-010-194-080
CAP, CHIP 0.047
C904
87-010-177-080
C-CAP,S 820P-50 SL
C905
87-010-196-080
CHIP CAPACITOR,0.1-25
LCD901
8A-KCG-610-010
LCD,AKC-16-17
LED951
87-A91-052-080
LED,SEL6227S RED
LED952
87-A91-052-080
LED,SEL6227S RED
LED953
87-A91-052-080
LED,SEL6227S RED
LED961
87-A40-813-040
C-LED,SEC1E01C BLUE
LED962
87-A40-813-040
C-LED,SEC1E01C BLUE
LED963
87-A40-813-040
C-LED,SEC1E01C BLUE
PL901
8Z-KT1-641-010
LAMP,T-3
PL902
8Z-KT1-641-010
LAMP,T-3
SW901
87-036-251-080
SW,T CT 6X3.5 160
SW902
87-036-251-080
SW,T CT 6X3.5 160
SW903
87-036-251-080
SW,T CT 6X3.5 160
SW904
87-036-251-080
SW,T CT 6X3.5 160
SW905
87-036-251-080
SW,T CT 6X3.5 160
SW906
87-036-251-080
SW,T CT 6X3.5 160
SW907
87-036-251-080
SW,T CT 6X3.5 160
SW908
87-036-251-080
SW,T CT 6X3.5 160
SW910
87-036-251-080
SW,T CT 6X3.5 160
SW911
87-036-251-080
SW,T CT 6X3.5 160
SW913
87-036-251-080
SW,T CT 6X3.5 160
SW914
87-036-251-080
SW,T CT 6X3.5 160
SW915
87-036-251-080
SW,T CT 6X3.5 160
SW916
87-036-251-080
SW,T CT 6X3.5 160
SW917
87-036-251-080
SW,T CT 6X3.5 160
SW918
87-036-251-080
SW,T CT 6X3.5 160
SW921
87-A91-597-010
SW,RTRY SIM-026MT
SW971
87-036-251-080
SW,T CT 6X3.5 160
AUX C.B
CON831
87-A60-912-010
CONN,3P V 1MSA-9202B-1
J831
85-HRL-623-010
JACK,3.5 ST BLK
!