SERVICE MANUAL
DA
TA
STEREO CAR CD RECEIVER
CDC-X217
CDC-X2170
CDC-X3170
CDC-X4170
YZ
YL
YL
YL
S/M Code No. 09-012-441-1R2
REVISION
BASIC CD MECHANISM: TN-CCD1001Z-152J
· This Service Manual is the "Revision Publishing" and replaces "Simple Manual"
of CDC-X217 / X2170 / X3170 / X4170<YZ,YL>, (S/M Code No. 09-011-441-1T2).
2
SPECIFICATIONS
RADIO SECTION <YL>
(FM)
Frequency Range
87.5 MHz 108 MHz (100-kHz steps)*
87.5 MHz 108 MHz (50-kHz steps)*
Usable Sensitivity
12.7 dBf
50 dB Quieting Sensitivity 17.2 dBf
IF Rejection
80 dB
Frequency Response
30 Hz 15,000 Hz
S/N Ratio
63 dB
Stereo Separation
35 dB at 1 kHz
Alternate Channel Selectivity
70 dB
Capture Ratio
3 dB
(AM)
Frequency Range
530 kHz 1,710 kHz (10-kHz steps)*
531 kHz 1,602 kHz (9-kHz steps)*
Usable Sensitivity
30
µV (30 dB)
9K
10K
* Set the frequency increment for your area using the switch on the bottom
of the unit.
(The switch is set at the factory to the 10k position.)
RADIO SECTION <YZ>
(FM)
Frequency Range
87.5 MHz 108 MHz (50-kHz steps)
Usable Sensitivity
12.7 dBf
50 dB Quieting Sensitivity 17.2 dBf
IF Rejection
80 dB
Frequency Response
30 Hz 15,000 Hz
S/N Ratio
63 dB
Stereo Separation
35 dB at 1 kHz
Alternate Channel Selectivity
70 dB
Capture Ratio
3 dB
(MW)
Frequency Range
530 kHz 1,710 kHz (10-kHz steps)*
531 kHz 1,602 kHz (9-kHz steps)*
Usable Sensitivity
30
µV (30 dB)
(LW)
Frequency Range
144 kHz 288 kHz (1-kHz / 9-kHz steps)*
Usable Sensitivity
30
µV (30 dB)
9K
10K
* Set the frequency increment for your area using the switch on the bottom
of the unit.
(The switch is set at the factory to the 9k position.)
CD SECTION
Frequency Response
17 Hz 20 kHz +0/3 dB
Dynamic Range
More than 80 dB
Channel Separation
More than 65 dB
S/N Ratio
More than 85 dB
Wow/Flutter
Unmeasurable
AUDIO SECTION
Max. Power Output
45 W x 4 channels
AUX IN input
Input Sensitivity (load impedance)
AUX IN
300 mV (10 k
)
GENERAL
Power Supply Voltage
14.4 V (11 to 16 V allowable),
DC, negative ground
Load Impedance
4
Tone Control
Bass
±10 dB at 100 Hz
Treble
±10 dB at 10 kHz
Preamp Output Voltage (load impedance)
2.2 V (10 k
)
Installation Size
182 (W) x 53 (H) x 155 (D) mm
(71/
4 (W) x 2
1/
8 (H) x 6
1/
8 (D) inches)
STEERING-WHEEL-MOUNTED REMOTE CONTROL UNIT <CDC-
X3170 / X4170 only>
Dimensions
Approx. 67 (W) x 26 (H) x 27 (D) mm
(23/
4 (W) x 1
1/
16 (H) x 1
1/
8 (D) inches)
(excluding holder)
Weight
Approx. 38g (1.33 oz.)
(including holder, battery)
· Design and specifications are subject to change without notice.
3
Precaution to replace Optical block
(OPTIMA-720L1E)
Body or clothes electrostatic potential could
ruin laser diode in the optical block. Be sure
ground body and workbench, and use care
the clothes do not touch the diode.
1) After the connection, remove solder
shown in right figure.
CLASS 1
LASER PRODUCT
KLASSE 1
LASER PRODUKT
LUOKAN 1
LASER LAITE
KLASS 1
LASER APPARAT
This set employs laser. Therefore, be sure to follow carefully
the instructions below when servicing.
WARNING!!
WHEN SERVICING, DO NOT APPROACH THE LASER
EXIT WITH THE EYE TOO CLOSELY. IN CASE IT IS
NECESSARY TO CONFIRM LASER BEAM EMISSION.
BE SURE TO OBSERVE FROM A DISTANCE OF MORE
THAN 30cm FROM THE SURFACE OF THE OBJEC-
TIVE LENS ON THE OPTICAL PICK-UP BLOCK.
s Caution: Invisible laser radiation when
open and interlocks defeated avoid
exposure to beam.
s Advarsel: Usynlig laserståling ved åbning,
når sikkerhedsafbrydere er ude af funktion.
Undgå udsættelse for stråling.
VAROITUS!
Laiteen Käyttäminen muulla kuin tässä käyttöohjeessa
mainitulla
tavalla
saataa
altistaa
käyt-täjän
turvallisuusluokan 1 ylittävälle näkymättömälle
lasersäteilylle.
VARNING!
Om apparaten används på annat sätt än vad som
specificeras i denna bruksanvising, kan användaren
utsättas för osynling laserstrålning, som överskrider
gränsen för laserklass 1.
PROTECTION OF EYES FROM LASER BEAM DURING SERVICING
CAUTION
Use of controls or adjustments or performance of proce-
dures other than those specified herin may result in
hazardous radiation exposure.
ATTENTION
L'utillisation de commandes, réglages ou procédures
autres que ceux spécifiés peut entraîner une dangereuse
exposition aux radiations.
ADVARSEL
Usynlig laserståling ved åbning, når sikkerhedsafbrydereer
ude af funktion. Undgå udsættelse for stråling.
This Compact Disc player is classified as a CLASS 1
LASER product.
The CLASS 1 LASER PRODUCT label is located on the
rear exterior.
PICK-UP ASSY
PWB
Solder
CAUTION WHEN SERVICING
(1) Using extension jigs
When the function of CD mechanism (TN-CCD1001Z-152J) is checked, connect between MAIN P.W.B and CD mechanism with the
extension jigs.
·
As the connection connector has no polar directions, check the direction of the circuit board (BKC-JIG1/2) when installing. (Refer to
the PIN number in the above photo.)
Parts name
JIG-BKC
Parts number
SV-J00-106-010
4
Extension jig
MAIN P.W.B
BKC-JIG(1)
Bottom View
CD Mechanism
13
14
26
1
14
1
13
26
BKC-JIG(2)
KANRI
NO.
REF. NO.
DESCRIPTION
PART NO.
KANRI
NO.
REF. NO.
DESCRIPTION
PART NO.
5
ELETRICAL MAIN PARTS LIST
IC
87-A20-446-010
C-IC,LA9241ML
87-A21-319-010
C-IC,LC78622NE
87-A21-488-040
C-IC,LA6556
8Z-KT1-622-010
C-IC,LC75374E
87-A21-562-010
IC,LA4743B
88-KT1-606-080
IC,PST994D
87-A21-906-030
C-IC,LC72358N-9A04<*EXP X217>
87-A21-934-030
C-IC,LC72358N-9A12<X217>
87-A21-489-030
C-IC,LC75853NW
87-A90-951-010
RCR UNIT,SBX1971-52<X3170,X4170>
TRANSISTOR
89-324-122-040
C-TR,2SC2412KR
87-A30-289-040
C-TR,2SA1037AK(R)
87-A30-288-040
C-TR,DTC114YKA
87-A30-287-040
C-TR,DTC114TKA
87-A30-435-040
C-TR,DTC144EKA
87-A30-299-080
TR,2SB1326
87-A30-282-040
C-TR,DTA114TKA
89-213-750-010
TR,2SB1375 (25W)
89-420-120-010
TR,2SD2012 (25W)
87-A30-427-040
C-TR,DTC114EKA
87-A30-301-080
TR,2SD1862
DIODE
87-A40-250-040
C-DIODE,DAN217
87-001-783-080
DIODE,1N4002
87-020-331-080
CHIP-DIODE,DAN202K
87-A40-650-080
ZENER,MTZJ6.8A
87-A40-523-080
ZENER,MTZJ9.1B
87-070-136-080
ZENER,MTZJ5.1B
87-017-932-080
ZENER,MTZJ6.2B
87-070-334-080
ZENER,MTZJ10B
87-A40-798-010
DIODE,1N5402 (3A/200V)
87-A40-817-040
C-ZENER,STZ6.8N
MAIN C.B
C101
87-012-274-080
CHIP CAP,U 1000P-50B
C102
87-012-286-080
CAP, U 0.01-25
C103
87-010-495-040
CAP,E 2.2-50 GAS
C106
87-012-282-080
CAP, U 4700P-50
C107
87-010-552-040
CAP,E 22-16 GAS
C108
87-012-195-080
C-CAP,U 100P-50CH
C109
87-010-553-040
CAP,E 47-16 GAS
C110
87-010-787-080
CAP, U 0.022-25
C111
87-010-553-040
CAP,E 47-16 GAS
C112
87-012-281-080
C-CAP,U 3900P-50 B
C113
87-012-286-080
CAP, U 0.01-25
C114
87-010-759-080
C-CAP,U, 0.1-25F
C115
87-010-759-080
C-CAP,U, 0.1-25F
C116
87-010-759-080
C-CAP,U, 0.1-25F
C131
87-A11-228-080
C-CAP,U 0.027-25 K B<*EXP X217>
C131
87-010-786-080
C-CAP,U 0.018-25 K B<X217>
C132
87-A11-228-080
C-CAP,U 0.027-25 K B<*EXP X217>
C132
87-010-786-080
C-CAP,U 0.018-25 K B<X217>
C133
87-A10-707-080
C-CAP,U 0.47U-16 F Z
C134
87-A10-707-080
C-CAP,U 0.47U-16 F Z
C140
87-012-282-080
CAP, U 4700P-50
C173
87-012-195-080
C-CAP,U 100P-50CH
C176
87-012-286-080
CAP, U 0.01-25
C201
87-010-553-040
CAP,E 47-16 GAS
C202
87-010-553-040
CAP,E 47-16 GAS
C203
87-012-274-080
CHIP CAP,U 1000P-50B
C204
87-A10-260-080
C-CAP,U 0.1-16 K B
C205
87-A10-353-080
C-CAP,U0.22-10KB
C206
87-010-492-040
CAP,E 0.33-50 GAS
C207
87-010-956-080
CHIP-CAP,S 0.068-25B
C208
87-012-272-080
C-CAP,U 680P-50 B
C209
87-A10-504-080
C-CAP,U 0.047-16 K B
C210
87-A10-260-080
C-CAP,U 0.1-16 K B
C211
87-010-498-040
CAP,E 10-16 GAS
C212
87-012-276-080
CAP, CHIP SS 1500 PBK
C213
87-A10-504-080
C-CAP,U 0.047-16 K B
C214
87-A10-260-080
C-CAP,U 0.1-16 K B
C215
87-012-278-080
C-CAP,U 2200P-50 B
C216
87-A10-353-080
C-CAP,U0.22-10KB
C217
87-A10-260-080
C-CAP,U 0.1-16 K B
C218
87-010-787-080
CAP, U 0.022-25
C219
87-012-268-080
C-CAP,U 330P-50 B
C220
87-012-280-080
CAP, U 3300P-50
C221
87-012-195-080
C-CAP,U 100P-50CH
C222
87-010-492-040
CAP,E 0.33-50 GAS
C223
87-010-067-040
CAP,E 0.1-50 5L
C224
87-010-553-040
CAP,E 47-16 GAS
C225
87-012-280-080
CAP, U 3300P-50
C226
87-010-497-040
CAP,E 4.7-35 GAS
C227
87-010-555-040
CAP,E 100-10 GAS
C228
87-A10-260-080
C-CAP,U 0.1-16 K B
C229
87-010-498-040
CAP,E 10-16 GAS
C230
87-A10-260-080
C-CAP,U 0.1-16 K B
C231
87-010-555-040
CAP,E 100-10 GAS
C232
87-A10-260-080
C-CAP,U 0.1-16 K B
C233
87-010-555-040
CAP,E 100-10 GAS
C234
87-010-828-080
CHIP CAPACITOR,U 0.033-25F
C235
87-A10-504-080
C-CAP,U 0.047-16 K B
C236
87-010-067-040
CAP,E 0.1-50 5L
C237
87-010-553-040
CAP,E 47-16 GAS
C238
87-012-286-080
CAP, U 0.01-25
C240
87-A10-260-080
C-CAP,U 0.1-16 K B
C250
87-A10-047-080
C-CAP,U 1-10 Z F
C251
87-010-555-040
CAP,E 100-10 GAS
C252
87-A10-260-080
C-CAP,U 0.1-16 K B
C253
87-A10-260-080
C-CAP,U 0.1-16 K B
C254
87-A10-260-080
C-CAP,U 0.1-16 K B
C256
87-012-282-080
CAP, U 4700P-50
C258
87-012-168-080
C-CAP,U 6P-50 CH
C259
87-012-184-080
C-CAP,U 33P-50 CH
C261
87-012-199-080
CAP
220P
C262
87-A10-260-080
C-CAP,U 0.1-16 K B
C263
87-010-555-040
CAP,E 100-10 GAS
C264
87-010-555-040
CAP,E 100-10 GAS
C265
87-A10-260-080
C-CAP,U 0.1-16 K B
C266
87-A10-260-080
C-CAP,U 0.1-16 K B
C267
87-010-498-040
CAP,E 10-16 GAS
C268
87-010-498-040
CAP,E 10-16 GAS
C269
87-012-276-080
CAP, CHIP SS 1500 PBK
C270
87-012-276-080
CAP, CHIP SS 1500 PBK
C271
87-012-172-080
CAPACITOR CHIP U 10P CH
C272
87-012-172-080
CAPACITOR CHIP U 10P CH
C273
87-010-494-040
CAP,E 1-50 GAS
C274
87-010-494-040
CAP,E 1-50 GAS
C280
87-A10-189-040
CAP,E 220-10
C281
87-010-555-040
CAP,E 100-10 GAS
C282
87-A10-260-080
C-CAP,U 0.1-16 K B
C301
87-010-498-040
CAP,E 10-16 GAS
C302
87-010-498-040
CAP,E 10-16 GAS
C303
87-010-494-040
CAP,E 1-50 GAS
C304
87-010-494-040
CAP,E 1-50 GAS
C305
87-012-280-080
CAP, U 3300P-50
C306
87-012-280-080
CAP, U 3300P-50
C307
87-010-198-080
CAP, CHIP 0.022
C308
87-010-198-080
CAP, CHIP 0.022
C309
87-010-498-040
CAP,E 10-16 GAS
C310
87-010-498-040
CAP,E 10-16 GAS
C311
87-A10-781-080
C-CAP,U 0.15-10 K B
C312
87-A10-781-080
C-CAP,U 0.15-10 K B