SERVICE MANUAL
DA
TA
STEREO CAR CD RECEIVER
BASIC CD MECHANISM : BZG-3 BNF
CDC-R217YZ
S/M Code No. 09-01A-447-5R1
REVISION
This Service Manual is the "Revision Publishing" and replaces "Simple Manual"
of CDC-R217 (YZ), (S/M Code No. 09-017-447-5T1).
2
SPECIFICATIONS
RADIO SECTION
(FM)
Frequency Range: 87.5 MHz 108 MHz (50-kHz steps)
Usable Sensitivity: 12.7 dBf
50 dB Quieting Sensitivity: 17.2 dBf
IF Rejection: 80 dB
Frequency Response: 30 Hz 15,000 Hz
S/N Ratio: 63 dB
Stereo Separation: 35 dB at 1 kHz
Alternate Channel Selectivity: 70 dB
Capture Ratio: 3 dB
(MW)
Frequency Range: 531 kHz 1,602 kHz (9-kHz steps)
Usable Sensitivity: 30 µV (30 dB)
(LW)
Frequency Range: 144 kHz 288 kHz (1-kHz / 9-kHz steps)
Usable Sensitivity: 30 µV (30 dB)
CD SECTION
Frequency Response: 17 Hz 20 kHz +0/3 dB
Dynamic Range: More than 80 dB
Channel Separation: More than 65 dB
S/N Ratio: More than 85 dB
Wow/Flutter: Unmeasurable
Design and specifications are subject to change without notice.
AUDIO SECTION
Max. Power Output: 45 W x 4 channels
AUX IN input
Input Sensitivity (load impedance) AUX IN: 300 mV (10 k
W)
GENERAL
Power-Supply Voltage: 14.4 V (11 to 16 V allowable),
DC, negative ground
Load Impedance: 4
W
Tone Control: Bass ± 10 dB at 100 Hz, Treble ± 10 dB at 10 kHz
Preamp Output Voltage (load impedance): 2.2 V (10 k
W)
Installated Size: 182 (W) x 53 (H) x 155 (D) mm
(71/
4 (W) x 2
1
/
8 (H) x 6
1
/
8 (D) inches)
3
Precaution to replace Optical block
(OPTIMA-720JVC)
Body or clothes electrostatic potential could
ruin laser diode in the optical block. Be sure
ground body and workbench, and use care
the clothes do not touch the diode.
1) After the connection, remove solder
shown in right figure.
CLASS 1
LASER PRODUCT
KLASSE 1
LASER PRODUKT
LUOKAN 1
LASER LAITE
KLASS 1
LASER APPARAT
This set employs laser. Therefore, be sure to follow carefully
the instructions below when servicing.
WARNING!!
WHEN SERVICING, DO NOT APPROACH THE LASER
EXIT WITH THE EYE TOO CLOSELY. IN CASE IT IS
NECESSARY TO CONFIRM LASER BEAM EMISSION.
BE SURE TO OBSERVE FROM A DISTANCE OF MORE
THAN 30cm FROM THE SURFACE OF THE OBJEC-
TIVE LENS ON THE OPTICAL PICK-UP BLOCK.
s Caution: Invisible laser radiation when
open and interlocks defeated avoid
exposure to beam.
s Advarsel: Usynlig laserståling ved åbning,
når sikkerhedsafbrydere er ude af funktion.
Undgå udsættelse for stråling.
VAROITUS!
Laiteen Käyttäminen muulla kuin tässä käyttöohjeessa
mainitulla
tavalla
saataa
altistaa
käyt-täjän
turvallisuusluokan 1 ylittävälle näkymättömälle
lasersäteilylle.
VARNING!
Om apparaten används på annat sätt än vad som
specificeras i denna bruksanvising, kan användaren
utsättas för osynling laserstrålning, som överskrider
gränsen för laserklass 1.
PROTECTION OF EYES FROM LASER BEAM DURING SERVICING
CAUTION
Use of controls or adjustments or performance of proce-
dures other than those specified herin may result in
hazardous radiation exposure.
ATTENTION
L'utillisation de commandes, réglages ou procédures
autres que ceux spécifiés peut entraîner une dangereuse
exposition aux radiations.
ADVARSEL
Usynlig laserståling ved åbning, når sikkerhedsafbrydereer
ude af funktion. Undgå udsættelse for stråling.
This Compact Disc player is classified as a CLASS 1
LASER product.
The CLASS 1 LASER PRODUCT label is located on the
rear exterior.
PICK-UP ASSY
PWB
Solder
4
CAUTION WHEN SERVICING
Precautions to be taken during servicing
(1) Using extension jigs
Connect between MAIN P.W.B. and CD mechanism with an extension jig during function check of CD mechanism.
Check the PIN number of circuit board (BKC-JIG 1 / 2) before installing a jig circuit board. (See the photo)
Parts name
BKC-JIG
Parts number
SV-J00-106-010
CD Mechanism
Extension jig
MAIN P.W.B
BOTTOM view
BKC-JIG(1)
BKC-JIG(2)
1
14
26
13
1
14
26
13
5
ELECTRICAL MAIN PARTS LIST
DESCRIPTION
REF. NO.
KANRI
NO.
PART NO.
DESCRIPTION
REF. NO.
KANRI
NO.
PART NO.
IC
88-KT1-607-080
C-IC,SAA6579T
88-KT1-606-080
IC,PST994D
8Z-KT1-622-010
C-IC,LC75374E
87-A21-562-010
IC,LA4743B
88-KT1-608-010
C-IC,LC75854W
87-A22-080-040
C-IC,LA6557H
87-A22-081-040
C-IC,TA2153FN
87-A22-079-030
C-IC,TC94A09F-300
87-A21-419-040
C-IC,NJM14558MD-TE2
87-A22-100-030
C-IC,UPD178018AGC-617-3B9
TRANSISTOR
87-A30-287-040
C-TR,DTC114TKA
87-A30-289-040
C-TR,2SA1037AK(Q)
89-324-122-040
C-TR,2SC2412KR
87-A30-288-040
C-TR,DTC114YKA
87-A30-290-010
TR,KTA1658(Y)
87-A30-291-010
TR,KTC4369(Y)
89-418-580-080
TR,2SD1858TV2
87-A30-283-040
C-TR,DTA114YKA
87-A30-282-040
C-TR,DTA114TKA
87-A30-299-080
TR,2SB1326
DIODE
87-A40-250-040
C-DIODE,DAN217
87-070-136-080
ZENER,MTZJ5.1B
87-070-334-080
ZENER,MTZJ10B
87-020-331-040
C-DIODE,DAN202K
87-A40-523-080
ZENER,MTZJ9.1B
87-017-932-080
ZENER,MTZJ6.2B
87-020-330-040
C-DIODE,DAP202K
87-A40-798-010
DIODE,1N5402 (3A/200V)
87-020-465-080
DIODE,1SS133
87-A40-337-080
ZENER,MTZJ 6.8B
87-001-783-080
DIODE,1N4002
87-A40-650-080
ZENER,MTZJ6.8A
87-020-585-080
C-ZENER,02CZ6.2Y
MAIN C.B
ANT101
8Z-KT1-614-010
ANT,AW-002
C101
87-012-274-080
C-CAP,U 1000P-50 K B
C102
87-012-286-080
C-CAP,U 0.01-25 K B
C103
87-012-274-080
C-CAP,U 1000P-50 K B
C104
87-012-282-080
C-CAP,U 4700P-50 K B
C105
87-010-490-040
CAP,E 0.1-50 M 5L MA
C107
87-010-553-040
CAP,E 47-16 M 5L SRE
C108
87-012-195-080
C-CAP,U 100P-50 J CH
C109
87-012-286-080
C-CAP,U 0.01-25 K B
C110
87-010-380-040
CAP,E 47-16 M 11L SME
C111
87-010-759-080
C-CAP,U 0.1-25 Z F
C112
87-012-286-080
C-CAP,U 0.01-25 K B
C113
87-010-759-080
C-CAP,U 0.1-25 Z F
C115
87-012-274-080
C-CAP,U 1000P-50 K B
C116
87-012-286-080
C-CAP,U 0.01-25 K B
C117
87-010-787-080
C-CAP,U 0.022-25 K B
C118
87-012-286-080
C-CAP,U 0.01-25 K B
C119
87-010-495-040
CAP,E 2.2-50 M 5L SRE
C120
87-012-281-080
C-CAP,U 3900P-50 K B GRM
C121
87-010-786-080
C-CAP,U 0.018-25 K B GRM
C122
87-010-786-080
C-CAP,U 0.018-25 K B GRM
C123
87-A10-707-080
C-CAP,U 0.47-10 Z F
C124
87-A10-707-080
C-CAP,U 0.47-10 Z F
C151
87-012-183-080
C-CAP,U 30P-50 J CH
C152
87-012-182-080
C-CAP,U 27P-50 J CH
C153
87-010-495-040
CAP,E 2.2-50 M 5L SRE
C154
87-012-268-080
C-CAP,U 330P-50 K B GRM
C155
87-012-271-080
C-CAP,U 560P-50 K B
C156
87-010-759-080
C-CAP,U 0.1-25 Z F
C157
87-010-553-040
CAP,E 47-16 M 5L SRE
C160
87-010-244-040
CAP,E 22-16 M 5L SRE
C202
87-A11-729-080
C-CAP,S 0.47-25 Z F
C203
87-A12-317-080
C-CAP,U 0.1-50 Z F
C205
87-010-553-040
CAP,E 47-16 M 5L SRE
C206
87-010-787-080
C-CAP,U 0.022-25 K B
C207
87-010-759-080
C-CAP,U 0.1-25 Z F
C208
87-010-759-080
C-CAP,U 0.1-25 Z F
C209
87-010-759-080
C-CAP,U 0.1-25 Z F
C211
87-010-787-080
C-CAP,U 0.022-25 K B
C212
87-010-759-080
C-CAP,U 0.1-25 Z F
C214
87-010-759-080
C-CAP,U 0.1-25 Z F
C216
87-010-787-080
C-CAP,U 0.022-25 K B
C219
87-012-278-080
C-CAP,U 2200P-50 K B
C220
87-010-553-040
CAP,E 47-16 M 5L SRE
C251
87-A12-317-080
C-CAP,U 0.1-50 Z F
C252
87-012-278-080
C-CAP,U 2200P-50 K B
C301
87-010-498-040
CAP,E 10-16 M 5L SRE
C302
87-010-498-040
CAP,E 10-16 M 5L SRE
C303
87-A10-047-080
C-CAP,U 1-10 Z F
C304
87-A10-047-080
C-CAP,U 1-10 Z F
C305
87-012-280-080
C-CAP,U 3300P-50 K B
C306
87-012-280-080
C-CAP,U 3300P-50 K B
C307
87-010-787-080
C-CAP,U 0.022-25 K B
C308
87-010-787-080
C-CAP,U 0.022-25 K B
C309
87-010-498-040
CAP,E 10-16 M 5L SRE
C310
87-010-498-040
CAP,E 10-16 M 5L SRE
C311
87-A10-781-080
C-CAP,U 0.15-10 K B
C312
87-A10-781-080
C-CAP,U 0.15-10 K B
C313
87-A10-781-080
C-CAP,U 0.15-10 K B
C314
87-A10-781-080
C-CAP,U 0.15-10 K B
C315
87-010-498-040
CAP,E 10-16 M 5L SRE
C316
87-010-498-040
CAP,E 10-16 M 5L SRE
C317
87-010-759-080
C-CAP,U 0.1-25 Z F
C318
87-010-498-040
CAP,E 10-16 M 5L SRE
C319
87-010-498-040
CAP,E 10-16 M 5L SRE
C321
87-010-555-040
CAP,E 100-10 M 5L SRE
C322
87-010-787-080
C-CAP,U 0.022-25 K B
C331
87-010-498-040
CAP,E 10-16 M 5L SRE
C332
87-010-498-040
CAP,E 10-16 M 5L SRE
C333
87-010-498-040
CAP,E 10-16 M 5L SRE
C334
87-010-498-040
CAP,E 10-16 M 5L SRE
C339
87-A10-047-080
C-CAP,U 1-10 Z F
C340
87-A10-047-080
C-CAP,U 1-10 Z F
C342
87-012-270-080
C-CAP,U 470P-50 K B
C344
87-012-270-080
C-CAP,U 470P-50 K B
C401
87-010-494-040
CAP,E 1-50 M 5L SRE
C405
87-010-759-080
C-CAP,U 0.1-25 Z F
C406
87-010-759-080
C-CAP,U 0.1-25 Z F
C407
87-A10-707-080
C-CAP,U 0.47-10 Z F
C408
87-A10-707-080
C-CAP,U 0.47-10 Z F
C409
87-A10-047-080
C-CAP,U 1-10 Z F
C410
87-A10-047-080
C-CAP,U 1-10 Z F
C451
87-A10-707-080
C-CAP,U 0.47-10 Z F
C452
87-A10-707-080
C-CAP,U 0.47-10 Z F
C453
87-A10-707-080
C-CAP,U 0.47-10 Z F
C454
87-012-286-080
C-CAP,U 0.01-25 K B
C501
87-A11-729-080
C-CAP,S 0.47-25 Z F
C502
87-A11-729-080
C-CAP,S 0.47-25 Z F
C503
87-A11-729-080
C-CAP,S 0.47-25 Z F
C504
87-A11-729-080
C-CAP,S 0.47-25 Z F
C505
87-012-271-080
C-CAP,U 560P-50 K B
C506
87-012-271-080
C-CAP,U 560P-50 K B
C507
87-012-271-080
C-CAP,U 560P-50 K B
C508
87-012-271-080
C-CAP,U 560P-50 K B
C509
87-A10-047-080
C-CAP,U 1-10 Z F
C510
87-010-553-040
CAP,E 47-16 M 5L SRE
C511
87-A12-317-080
C-CAP,U 0.1-50 Z F